Reduction potential of microbial, odour and ammonia emissions from a pig facility by biofilters.

The intention of this study was the determination of the potential to reduce specific microbial bioaerosol (cultivable bacteria and fungi, total cell counts of microbes, airborne endotoxins and microbial volatile organic compounds, MVOC), odour and ammonia emissions from a pig facility by biofilters. Five identical biofilter units in half technical scale were filled with different filter materials (Biochips, coconut-peat, wood-bark, pellets + bark and compost) and connected in parallel to a piggery. The results showed obvious differences between the filter materials. Numbers of airborne cultivable bacteria were decreased by ca. 70 to 95% and the total counts of bacterial cells from ca. 25 to (>) 90%. The total amount of fungal cells was reduced by at least 60%, although the percentage of cultivable moulds in the air after passing the filters was sometimes higher than before. Airborne endotoxins and MVOC were effectively reduced by all filter materials to at least 90%. Regarding odour, the average reduction was between 40 and 83%, whereas only one of the filters proved to be capable of slightly reducing the ammonia emissions. No relationships between odour/ammonia and microbial bioaerosols with regard to the reduction efficiency of the different filter materials or the total load of the emitted air could be established. A tendency could be shown, that biofilters best capable to reduce odour emitted slightly more airborne bacteria, both cultivable and total cell counts.

Biofilters--the influence of different filter materials and different operating conditions on the reduction efficiency.

A series of biofilter materials were tested for performance efficiency in treating ventilation air from pig sheds. Two different phases were conducted. In phase A five different biofilter materials were tested with the aim of selecting the best material regarding the odor reduction and over all efficiency. In conclusion of phase A, biochips, a new filter material, was selected due to its high average odor reduction (81%) in combination with a very low flow resistance (less than 30 Pa for filter volume loads of 600 m3 h(-1) m(-3)). In phase B, biochips and coconut fiber peat were tested under different operating conditions. Biofilters number 3 and 4 each with down-flow air supply could realize a higher average odor reduction than biofilter 5 with up-flow air supply. All three filter materials had the same moisture, however the two biofilters with down-flow air supply showed a more homogenous moisture distribution but they also used approximately three times more water than biofilter 5. Like in phase A the specific odor cleaning efficiency was mainly influenced by the specific odor loading rate and showed only slight differences between the five biofilters differing in bulk layer height (0.5 m and 1.0 m) and air supply mode. All in all the investigation showed that the efficiency of biofilters can be optimized by using an new filter material and a appropiate operating mode.