Middle-down fragmentation for the identification and quantitation of site-specific methionine oxidation in an IgG1 molecule.

A middle-down LC/MS approach, for the rapid quantitation and characterization of site-specific methionine oxidation in a recombinant monoclonal IgG1 molecule, is described. An IgG1 antibody was digested with endoprotease LysC under limited proteolytic conditions to produce two major components; an antigen binding fragment (Fab) and a crystallizable fraction (Fc). These fractions were then reduced to produce three major species; light chain (LC), Fc/2 which is the C terminal region of the heavy chain (HC) and the N-terminal heavy chain region (Fd). These three fragments were separated by reversed-phase HPLC using a diphenyl column. The diphenyl column resolved site-specific methionine oxidation in all three subunits. Middle-down N-terminal sequencing with a LCT premier mass spectrometer was used to identify the sites of oxidation in the LC. Sites of oxidation in the Fc/2 were identified using middle-down collision-induced dissociation (CID) on a Qtof premier. This method allowed for the rapid quantitation and identification of oxidation on each methionine residue in an IgG1 molecule.

An improved trypsin digestion method minimizes digestion-induced modifications on proteins.

Trypsin digestion can induce artificial modifications such as asparagine deamidation and N-terminal glutamine cyclization on proteins due to the temperature and the alkaline pH buffers used during digestion. The amount of these artificial modifications is directly proportional to the incubation time of protein samples in the reduction/alkylation buffer and, more important, in the digestion buffer where the peptides are completely solvent exposed. To minimize these artificial modifications, we focused on minimizing the trypsin digestion time by maximizing trypsin activity. Trypsin activity was optimized by the complete removal of guanidine, which is a known trypsin inhibitor, from the digestion buffer. As a result, near complete trypsin digestion was achieved on reduced and alkylated immunoglobulin gamma molecules in 30min. The protein tryptic fragments and their modification products were analyzed and quantified by reversed-phase liquid chromatography/tandem mass spectrometry using an in-line LTQ Orbitrap mass spectrometer. The reduction and alkylation reaction time was also minimized by monitoring the completeness of the reaction using a high-resolution time-of-flight mass spectrometer. Using this 30-min in-solution trypsin digestion method, little protocol-induced deamidation or N-terminal glutamine cyclization product was observed and cleaner tryptic maps were obtained due to less trypsin self-digestion and fewer nonspecific cleavages. The throughput of trypsin digestion was also improved significantly compared with conventional trypsin digestion methods.

Top-down N-terminal sequencing of Immunoglobulin subunits with electrospray ionization time of flight mass spectrometry.

An N-terminal top-down sequencing approach was developed for IgG characterization, using high-resolution HPLC separation and collisionally activated dissociation (CAD) on a single-stage LCT Premier time of flight (TOF) mass spectrometer. Fragmentation of the IgG chains on the LCT Premier was optimized by varying the ion guide voltage values. Ion guide 1 voltage had the most significant effect on the fragmentation of the IgG chains. An ion guide 1 voltage value of 100 V was found to be optimum for the N-terminal fragmentation of IgG heavy and light chains, which are approximately 50 and 25 kDa, respectively. The most prominent ion series in this CAD experiment was the terminal b-ion series which allows N-terminal sequencing. Using this technique, we were able to confirm the sequence of up to seven N-terminal residues. Applications of this method for the identification of N-terminal pyroglutamic acid formation will be discussed. The method described could be used as a high-throughput method for the rapid N-terminal sequencing of IgG chains and for the detection of chemical modifications in the terminal residues.

Comparison of LC and LC/MS methods for quantifying N-glycosylation in recombinant IgGs.

High-performance liquid chromatography (LC) and liquid chromatography/electrospray ionization time-of-flight mass spectrometry (LC/ESI-MS) methods with various sample preparation schemes were compared for their ability to identify and quantify glycoforms in two different production lots of a recombinant monoclonal IgG1 antibody. IgG1s contain a conserved N-glycosylation site in the fragment crystallizable (Fc) subunit. Six methods were compared: (1) LC/ESI-MS analysis of intact IgG, (2) LC/ESI-MS analysis of the Fc fragment produced by limited proteolysis with Lys-C, (3) LC/ESI-MS analysis of the IgG heavy chain produced by reduction, (4) LC/ESI-MS analysis of Fc/2 fragment produced by limited proteolysis and reduction, (5) LC/MS analysis of the glycosylated tryptic fragment (293EEQYNSTYR301) using extracted ion chromatograms, and (6) normal phase HPLC analysis of N-glycans cleaved from the IgG using PNGase F. The results suggest that MS quantitation based on the analysis of Fc/2 (4) is accurate and gives results that are comparable to normal phase HPLC analysis of N-glycans (6).

Automated tryptic digestion procedure for HPLC/MS/MS peptide mapping of immunoglobulin gamma antibodies in pharmaceutics.

The rapid growth of antibody drugs and drug candidates in the biopharmaceutical industry has created a demand for automated proteolytic digestion to assist in pharmaceutical stability studies, identity assays and quality control of these therapeutic proteins. Here, we describe the development of a fully automated proteolytic digestion procedure for monoclonal antibodies in solution, which requires a high concentration of denaturants for unfolding. The antibody samples were placed in a 96-well plate or in 0.5-mL Eppendorf tubes. The proteins were then reduced and alkylated in a denaturing solution of 6M guanidine HCl. The denaturing solution was replaced with a digestion buffer using a custom-designed 96-well size-exclusion plate for desalting. The sample was digested for 5 h with two additions of trypsin. The completeness and reproducibility of digestion were verified by reversed-phase high-performance liquid chromatography tandem mass spectrometry (HPLC/MS) analysis of the digestion products. The performance of the automatic digestion was comparable to the currently used manual digestion procedure, but saved time, reduced manual labor, and increased the reproducibility of the tryptic digests. Our method should be useful not only for high-throughput analysis of antibodies, but for other therapeutic protein samples as well. Other applications like gel-free proteomics, where the analysis of a large number of samples is often needed and the completeness of the liquid digestion is critical for the identification of a large number of different proteins, should also benefit from this fully automated liquid proteolytic digestion procedure.

Characterization of IgG1 immunoglobulins and peptide-Fc fusion proteins by limited proteolysis in conjunction with LC-MS.

A combinatory approach for the characterization of post-translational and chemical modifications in high molecular weight therapeutic proteins like antibodies and peptide-Fc fusion proteins (MW > or = 50 000 Da) is presented. In this approach, well-established techniques such as limited proteolysis, reversed-phase (RP) high-performance liquid chromatography (HPLC), and in-line mass spectrometry (MS) were combined for the characterization of a monoclonal IgG1 antibody and three different peptide-Fc fusion proteins. The one commonality of these molecules is the presence of a similarly accessible lysine residue either located in the flexible hinge region of the antibody or in the flexible linker of the peptide-Fc fusion proteins. Applying limited proteolysis using endoproteinase Lys-C resulted in the predominant cleavage C-terminal of this lysine residue. The created fragments, two identical Fab domain fragments and one Fc domain fragment derived from the IgG1 antibody and one Fc domain fragment and each of the three individual peptide moieties generated from the peptide-Fc fusion proteins, were readily accessible for complete separation by RP-HPLC and detailed characterization by in-line MS analysis. This approach facilitated rapid detection of a variety of chemical modifications such as methionine oxidation, disulfide bond scrambling, and reduction as well as the characterization of various carbohydrate chains. We found limited proteolysis followed by RP-HPLC-MS to be less time-consuming for sample preparation, analysis, and data interpretation than traditional peptide mapping procedures. At the same time, the reduced sample complexity provided superior chromatographic and mass spectral resolution than the analysis of the corresponding intact molecules or a large number of enzymatically generated fragments.

Reversed-phase liquid chromatography-mass spectrometry of site-specific chemical modifications in intact immunoglobulin molecules and their fragments.

The employment of a diphenyl column for the separation of intact monoclonal antibodies (mAbs) and their fragments by reversed-phase HPLC is discussed as a novel approach for the characterization of chemical modifications in a site-specific manner. Chromatographic separation of the intact mAb07 on the diphenyl support resulted in the separation of the cysteinylated from the non-cysteinylated mAb. A detected mass increase of 119 Da by mass spectrometric sequence analysis confirmed the cysteinylation. Furthermore, the diphenyl column resolved site-specific oxidation of five different methionine residues in the heavy chain (HC) of mAb03. Oxidized mAb03 HC eluted as five distinct peaks with shorter retention times than the corresponding peak representing unoxidized HC. Analysis of these peaks by in-line mass spectrometric analysis confirmed the site-specific oxidation of five different methionine residues. In another application, the diphenyl column was able to resolve free sulfhydryl groups containing Fc and Fab fragments, which were generated by limited proteolysis with endoproteinase Lys-C. The free sulfhydryl groups were responsible for a mass shift of approximately 2 Da. Their identity was further confirmed by N-ethylmaleimide labeling, which caused a shift in their chromatographic retention and led to a mass increase of 250 Da. This is the first report about chromatographic resolution on a reversed-phase column that results in site-specific separation of chemical modifications in intact mAb and mAb fragments.

Removal of cysteinylation from an unpaired sulfhydryl in the variable region of a recombinant monoclonal IgG1 antibody improves homogeneity, stability, and biological activity.

The antibody MAB007 was recently shown to be cysteinylated on an unpaired cysteine residue in the CDR3 variable region. Cysteinylation at this position was not complete and resulted in heterogeneous lots of MAB007 with respect to this posttranslational modification. In this report, a mild redox step was used that effectively removed cysteinylation while keeping native inter and intra-molecular disulfide bonds intact. Biophysical methods were employed to determine what consequences cysteinylation of the variable region had by directly comparing cysteinylated and de-cysteinylated MAB007 antibodies. No differences were detected in secondary structure; however, several pieces of evidence indicated that cysteinylation may result in tertiary or quaternary structural perturbations. These included differences in the cation-exchange chromatography and fluorescence-emission spectra of the cysteinylated and de-cysteinylated antibodies as well as differences in the solvent accessibility of the unpaired cysteine residue determined by labeling experiments. Such structural changes induced by cysteinylation were shown to increase the rate of MAB007 aggregation and to decrease the melting temperature of the Fab region by as much as 6 degrees C. The bioactivity of MAB007 was also shown to be adversely affected by cysteinylation and a direct correlation was made between the percent cysteinylation and biological activity.

Reversed-phase liquid chromatography of immunoglobulin G molecules and their fragments with the diphenyl column.

A diphenyl column was able to resolve two closely related monoclonal IgG2 molecules, while a C8 column failed to separate these IgGs under identical chromatographic conditions. The diphenyl column also showed a better separation of a mixture of two light and two heavy chains than the C8 column. The influence of amino acid side chains from protein sequences in binding to the diphenyl and C8 stationary phases was studied by using a set of synthetic peptides with the sequence GXXLLLKK, where X represents substitution with all of the 20 amino acids. Peptides containing aromatic amino acids showed a greater binding on the diphenyl column than on the C8 column. This increase in retention was attributed to pi-pi interactions between the aromatic amino acid side chains and the diphenyl ligand. Based on the retention of peptides on the diphenyl column, new retention coefficients were assigned for the separation of proteins. A good correlation was observed between the sum of retention coefficients (SigmaRc) for IgGs and their retention time on the diphenyl column. On-column hydrogen-deuterium exchange showed that the diphenyl column had a larger surface of interaction with protein than the C8 column. pi-pi interactions and the large contact surface resulted in improved resolution of IgGs and their fragments on the diphenyl column.

The LC/MS analysis of glycation of IgG molecules in sucrose containing formulations.

Glycation of a recombinant monoclonal IgG2 molecule, in sucrose containing liquid formulations, was studied using reversed-phase LC/MS analysis of the intact IgG, the F(ab')2 fragments and after complete tryptic digestion. The extent of glycation in sucrose containing formulations was monitored at different temperatures over a period of 21 months using the Hexose index (Hex(I)). Hex(I) represents the average number of hexose molecules per molecule of IgG and was calculated by using the intensity values of peaks corresponding to hexose isoforms in the deconvoluted mass spectra. The rate of glycation in mildly acidic sucrose containing formulations was proportional to the incubation temperature. No glycation was observed in sucrose containing formulations incubated at 4 degrees C even after 18 months. However, when the same formulations were incubated at 37 degrees C glycation was observed after just 1 month. The glycation sites were mapped to 10 lysine residues distributed throughout the molecule. The amino terminal end of the light chain was also shown to contain glycation. The surface accessibility of the lysine side chain could influence its susceptibility to glycation.

Identification of cysteinylation of a free cysteine in the Fab region of a recombinant monoclonal IgG1 antibody using Lys-C limited proteolysis coupled with LC/MS analysis.

MAB007, an IgG1 monoclonal antibody, is unique because of the presence of a free cysteine residue in the Fab region at position 104 on the heavy chain in the CDR3 region. Mass spectrometric analysis of intact MAB007 showed multiple peaks varying in mass by 120-140 Da that cannot be fully attributed to glycosylation isoforms typically present in IgG molecules. Limited proteolysis of MAB007 with Lys-C led to a single cleavage at the C-terminus of a lysine residue in the hinge region of the heavy chain at position 222, generating free Fab and Fc fragments. Reversed-phase liquid chromatography/mass spectrometry analysis of the Fab and Fc fragments revealed several modifications. The Fab fraction showed cysteinylation of a free cysteine in the CDR3 region resulting in a mass shift of 119 Da. Using limited proteolysis, we also identified modifications resulting in a mass increase of 127 Da in the Fc region, corresponding to C-terminal lysine variants in the heavy chain. Other modifications, such as oxidation (+16 Da) and succinimide formation (-17 Da), were also detected in the Fab fragment. The cysteinylation observed after limited proteolysis was confirmed by peptide mapping coupled with tandem mass spectrometry analysis.

Improving mass accuracy of high performance liquid chromatography/electrospray ionization time-of-flight mass spectrometry of intact antibodies.

The glycosylation profile of intact antibody due to the galactose and fucose heterogeneity in the N-linked sugars was determined with instrument resolution of 5000 and 10,000. After deconvolution of electrospray ionization mass spectra to complete convergence, several extra peaks appeared in addition to the peaks observed in the original mass spectra. The artificial peaks were avoided if deconvolution was stopped after a smaller number of iterations. A standard antibody was used as an external calibrant to minimize mass measurement errors during long-period experiments. Precision of four consecutive LC/MS measurements of the same antibody was 10 ppm (+/-1.5 Da). By using this approach, the masses of 11 intact antibodies were measured. All antibodies containing N-terminal glutamines had a negative mass shift due to the formation of pyroglutamate (-17 Da). Although the pyroglutamate variant of intact antibody was not resolved from the unmodified variant, this modification led to a mass shift proportional to the percentage of N-terminal pyroglutamate. By accurately measuring the mass shift we were able to quantify the abundance of pyroglutamic acid on intact antibodies. Mass accuracy in measuring different antibodies was below 30 ppm (+/-4 Da). The accurate mass measurement can be an effective tool for monitoring chemical degradations in therapeutic antibodies.

Optimization of a reversed-phase high-performance liquid chromatography/mass spectrometry method for characterizing recombinant antibody heterogeneity and stability.

An enhanced analytical RP-HPLC/MS method was developed for monitoring the stability and production of intact and fragmented monoclonal antibodies (MAbs). The use of high column temperatures (70-80 degrees C), organic solvents with high eluotropic strength coefficients (isopropyl and n-propyl alcohols), and Zorbax StableBond columns, were critical for good recovery and resolution of immunoglobulin G1 (IgG1) and IgG2 monoclonal antibodies. Using this method, cleavage products of a degraded IgG1 antibody were clearly separated and identified by in-line electrospray ionization time-of-flight (ESI-TOF) mass spectrometry generating exact masses and unique terminal ladder sequences. The glycosylation profile, including mapping of the terminal galactose and fucose heterogeneity of the N-linked sugars, was determined by mass spectrometry of intact MAbs. In addition, we discovered that several IgG2 MAbs exhibited greater structural heterogeneity compared to IgG1s. Mass spectral characterization data and reduction data suggested that the heterogeneity is disulfide related. This reversed-phase LC/MS method represents a key advancement in monitoring intact MAb production and stability.

Active dimer of Epratuzumab provides insight into the complex nature of an antibody aggregate.

Understanding the intermolecular products of antibodies as a consequence of host-cell expression, aging, and heat-stress can be insightful especially when it involves the development of a stable biopharmaceutical product. The dimerized form of Epratuzumab (an IgG(1) antibody) with a molecular mass of approximately 300 kDa (twice the monomer antibody molecular weight of approximately 150 kDa) was examined to gain a better perspective of its properties pertaining to structure and activity. The nascent dimer was shown to partially dissociate upon incubation at 30 degrees C and 37 degrees C, exhibit no discernable alteration of structure (i.e., secondary or tertiary structure based on CD and 2nd derivative UV spectroscopy), have approximately 70% covalent forms (based upon CE-SDS results) and manifest twofold higher activity relative to the active monomer form (on a weight basis the dimer and monomer have equal activity). Interestingly, these properties were not attributed to a single dimer species, but rather to a more complex dimer assembly. The Epratuzumab dimer was digested with papain to reveal three uniquely dimerized aggregates. The relative molar distribution of Fab:Fab, Fc:Fc, and Fab:Fc was found to be 4:3:8, respectively. The data suggest that all three predominantly covalent dimer adducts are capable of full activity, shedding light on their complex nature and showing that their target specificity was unaltered. ESI-MS data indicated the presence of remnant levels of noncovalent dimers for all three dimerized forms. Material aged at 37 degrees C exhibited a similar papain digest molar distribution of the three dimerized forms, except with enhanced chemical heterogeneity and an increase in covalent forms to approximately 84%.

Reversed-phase liquid chromatography/mass spectrometry analysis of reduced monoclonal antibodies in pharmaceutics.

A reversed-phase LC/MS method was developed for reduced antibodies that provides efficient separation of light chain and two variants of heavy chain containing N-terminal glutamine and pyroglutamic acid. The best separation was achieved on Zorbax CN and Varian Pursuit DiPhenyl columns eluted with increasing percentage of n-propanol and acetonitrile in 0.1% trifluoroacetic acid. Although glutamine was genetically coded for the N-terminal residue of heavy chain of a monoclonal antibody used in this study, we found that most of it (70%) was converted to pyroglutamate during production. The conversion process continued in vitro and was monitored by the method. Deconvoluted electrospray ionization mass spectrum of the heavy chain revealed the glycosylation profile of a single N-linked sugar including a-, mono-, and di-galactosylated biantennary glycans and a 5-mannose sugar form.

Aggregation of granulocyte-colony stimulating factor in vitro involves a conformationally altered monomeric state.

Aggregation of partially folded intermediates populated during protein folding processes has been described for many proteins. Likewise, partially unfolded chains, generated by perturbation of numerous proteins by heat or chemical denaturants, have also been shown to aggregate readily. However, the process of protein aggregation from native-state conditions is less well understood. Granulocyte-colony stimulating factor (G-CSF), a member of the four-helix bundle class of cytokines, is a therapeutically relevant protein involved in stimulating the growth and maturation of phagocytotic white blood cells. Under native-like conditions (37 degrees C [pH 7.0]), G-CSF shows a significant propensity to aggregate. Our data suggest that under these conditions, native G-CSF exists in equilibrium with an altered conformation, which is highly aggregation prone. This species is enriched in 1-2 M GdmCl, as determined by tryptophan fluorescence and increased aggregation kinetics. In particular, specific changes in Trp58 fluorescence report a local rearrangement in the large loop region between helices A and B. However, circular dichroism, reactivity toward cyanylation, and ANS binding demonstrate that this conformational change is subtle, having no substantial disruption of secondary and tertiary structure, reactivity of the free sulfhydryl at Cys17 or exposure of buried hydrophobic regions. There is no indication that this altered conformation is important to biological activity, making it an attractive target for rational protein stabilization.

Optimization and applications of CDAP labeling for the assignment of cysteines.

PURPOSE: The aim of the study is to provide a methodology for assigning unpaired cysteine residues in proteins formulated in a variety of different conditions to identify structural heterogeneity as a potential cause for protein degradation. METHODS: 1-Cyano-4-dimethylaminopyridinium tetrafluoroborate (CDAP) was employed for cyanylating free cysteines in proteins and peptides. Subsequent basic cleavage of the peptide bond at the N-terminal side of the cyanylated cysteines provided direct information about their location. RESULTS: CDAP was successfully employed to a wide variety of labeling conditions. CDAP was reactive between pH 2.0 and 8.0 with a maximum labeling efficiency at pH 5.0. Its reactivity was not affected by excipients, salt or denaturant. Storing CDAP in an organic solvent increased its intrinsic stability. It was demonstrated that CDAP can be employed as a thiol-directed probe to investigate structural heterogeneity of proteins by examining the accessibility of unpaired cysteine residues. CONCLUSION: CDAP is a unique cysteine-labeling reagent because it is reactive under acidic conditions. This provides an advantage over other sulfhydryl labeling reagents as it avoids potential thiol-disulfide exchange. Optimization of the cyanylation reaction allowed the utilization of CDAP as a thiol-directed probe to investigate accessibility of sulfhydryl groups in proteins under various formulation conditions to monitor structural heterogeneity.