Isolation and characterization of naphthenic acids from Athabasca oil sands tailings pond water.

A laboratory bench procedure was developed to efficiently extract naphthenic acids from bulk volumes of Athabasca oil sands tailings pond water (TPW) for use in mammalian oral toxicity testing. This solvent-based procedure involved low solvent losses and a good extraction yield with low levels of impurities. Importantly, labour-intensive centrifugation of source water to remove solids was avoided, allowing processing of much larger volumes of water compared with previous protocols. Naphthenic acids, present at an estimated concentration of 81 mg/l, were procured from 515.5 l of TPW at an overall extraction efficiency of approximately 85%. By using distillation to recover and recycle solvent, a high solvent:water ratio was maintained while actual solvent consumption was limited to 70 ml per liter of water processed. Electrospray ionization mass spectrometry suggested a highly heterogeneous naphthenic acid mixture that exhibited nearly identical proportions of monocyclic, polycyclic, and acyclic acids with molecular weights primarily between 220 and 360. Biphenyls, naphthalenes, and phenanthrene/anthracene were the most prominent impurities detected, but their levels were low (< or = 13 microg/l) even in a concentrated solution of the naphthenic acids (8549 mg/l). Naphthenic acids stored at 4 degrees C at this concentration were stable, exhibiting no significant change in concentration over a 10-month period. This bulk isolation procedure should be useful to others needing to process large volumes of tailings or other source water for the purpose of procuring moderate amounts of naphthenic acids.

Acute and subchronic mammalian toxicity of naphthenic acids from oil sands tailings.

Naphthenic acids are the most significant environmental contaminants resulting from petroleum extraction from oil sands deposits. In this study, a mixture of naphthenic acids isolated from Athabasca oil sands (AOS) tailings pond water was used in acute and subchronic toxicity tests with rodents, in order to assess potential risks posed to terrestrial wildlife. Dosages were chosen to bracket worst-case environmental exposure scenarios. In acute tests, adult female Wistar rats were given single po dosages of naphthenic acids at either 3, 30, or 300 mg per kg body weight (mg/kg), while adult male rats received 300 mg/kg. Food consumption was temporarily suppressed in the high-dose groups of both sexes. Following euthanasia 14 days later, histopathology revealed a significant incidence of pericholangitis in the high-dose group of both sexes, suggesting hepatotoxicity as an acute effect. Other histological lesions included brain hemorrhage in high-dose males, and cardiac periarteriolar necrosis and fibrosis in female rats. In subchronic tests, naphthenic acids were po administered to female Wistar rats at 0.6, 6, or 60 mg/kg, 5 days per week for 90 days. Results again suggested the liver as a potential target organ. The relative liver weight in the high-dose group was 35% higher than in controls. Biochemical analysis revealed elevated blood amylase (30% above controls) and hypocholesterolemia (43% below controls) in high-dose rats. Excessive hepatic glycogen accumulation was observed in 42% of animals in this group. These results indicate that, under worst-case exposure conditions, acute toxicity is unlikely in wild mammals exposed to naphthenic acids in AOS tailings pond water, but repeated exposure may have adverse health effects.