Enhancement of biological nutrient removal process with advanced process control tools in full-scale wastewater treatment plant.

One of the major challenges in existing WasteWater Treatment Plants (WWTPs) is to comply with the increasingly stringent nutrient discharge limits established by the competent authorities to enhance environmental protection, while keeping operation costs as low as possible. This paper describes the results obtained from upgrading a full-scale WWTP during seven years (2013-2020) applying five different Advanced Process Control (APC) strategies. Results show that implementation of APC and the development of ammonia-based aeration control, aeration/non-aeration cycles, improved internal/external recirculation and chemical dosage controls resulted in an improvement in nutrients removal rates (+25.48% and +9.25%, for nitrogen and phosphorus, respectively) and in a reduction (-21.79%) of the specific energy ratio. In addition, the promotion of an Enhanced Biological Phosphorous Removal (EBPR) process by APC resulted in an improvement in biological phosphorous removal (+43.90%), chemical savings (-20.00%) and nutrient recovery in the dewatered sludge. Molecular biology tools and laboratory batch tests confirmed the Polyphosphate Accumulating Organisms (PAOs) activity, specifically Tetrasphaera genera. Finally, an economic analysis was conducted, showing a rate of return for the incurred capital expenses with the implemented APC systems of about five years, being an affordable alternative to the upgrading existing WWTPs.

Improved anaerobic biodegradability of wheat straw, solid cattle manure and solid slaughterhouse by alkali, ultrasonic and alkali-ultrasonic pre-treatment.

Wheat straw and animal wastes are important feedstock for biogas production in Europe. Yet, the high content of lignocellulosic and refractory materials causes the process to be relatively slow. Therefore, pretreatment methods have been proposed to shorten the hydrolysis phase. The present study examined the effectiveness of alkali pre-treatment (AP), ultrasonic pre-treatment (UP), and alkali-ultrasonic pre-treatment (AUP) applied on wheat straw (WS), solid fraction of cattle manure (SCM) and solid fraction of slaughterhouse waste (SSHW), by monitoring solubilisation ratio, anaerobic biodegradability and methane yield. The results indicate that the solubilisation ratio of the substrates improved regardless of the types of pre-treatment applied. Though, AP was more effective on WS and SSHW than other pre-treatments (UP and AUP), with approximately 47% and 17% extra methane, respectively. Moreover, AP of SCM caused an increased in methane production rate by 100% and minimised lag phase from 16 days to 1 day during anaerobic digestion. Based on Danish conditions, only AP of WS was economical prior to the biogas process due to high extra methane yield. A positive energy budget of 8 € t-1 VS was calculated. High-energy consumption during UP and AUP in laboratory scale hindered the positive benefits of these pre-treatments.

Nitrite and free nitrous acid sludge pre-treatments to enhance methane production in continuous anaerobic digestion: Comparing process performance and associated costs.

Secondary sludge pre-treatment with free nitrous acid (FNA) has been proven to enhance methane production during anaerobic digestion. However, it is still unclear if the same enhancement can be achieved only using nitrite, without sludge acidification. In this paper, secondary sludge was pre-treated during 5 h with nitrite within the range of 50-250 mg NO2--N/L at neutral pH (6.7). Results obtained from biochemical methane potential tests (BMPs) indicated that sludge pre-treatment at 150 mg NO2--N/L presented the best enhancement of methane production (24% as compared to the control). These conditions were used to pre-treat sludge added in a continuous lab-scale anaerobic digester that operated in parallel to another digester receiving sludge pre-treated with FNA (250 mg NO2--N/L at pH 5.5). Results showed a very similar performance in terms of methane enhancement in both reactors, indicating that sludge acidification is not needed to improve methane yield. A preliminary economic assessment also highlights the need for assessing real chemical costs and national power prices before the implementation of these pre-treatment steps as the associated benefits can significantly change depending on the country where the wastewater treatment plant is located.

Diversity of opportunistic black fungi on babassu coconut shells, a rich source of esters and hydrocarbons.

The present study assessed the diversity of black yeast-like fungi present on babassu coconut shells, a substrate rich in lipids and several volatile organic compounds (VOCs) including aromatic hydrocarbons. Using different isolation methods, one-hundred-six isolates were obtained and were identified by ITS sequencing as members of the genera Exophiala, Cladophialophora, Veronaea, and Rhinocladiella. Two novel species were discovered. Eight strains were selected for assessing their ability to grow on toluene and phenyl acetate as the sole carbon and energy source. All strains tested were able to assimilate phenyl acetate, while two out of eight were able to use toluene. VOCs profiling in babassu samples was also investigated by GC-ToF MS, revealing that a complex mixture of VOCs was emitted, which included alkylbenzenes such as toluene. Assimilation of alkylbenzenes by the black yeasts might therefore be the result of evolutionary adaptation to symbiotic interactions with higher plants. The potential relationship between lipid/aromatic hydrocarbon metabolism and pathogenicity is also discussed.

Improvement of wheat straw anaerobic digestion through alkali pre-treatment: Carbohydrates bioavailability evaluation and economic feasibility.

Lignocellulosic biomasses such as wheat straw are widely used as a feedstock for biogas production. However, these biomasses are mainly composed of a compact fibre structure and therefore, it is recommended to treat them prior to its usage for biogas production in order to improve their bioavailability. The aim of this work is to evaluate, in terms of performance stability, methane yield and economic feasibility, two different scenarios: a mesophilic codigestion of wheat straw and animal manure with or without a low-energy demand alkaline pre-treatment (0.08gKOHgTS-1of wheat straw, for 24h and at 25°C). Besides this, said pre-treatment was also analysed based on the improvement of the bioavailable carbohydrate content in the untreated versus the pre-treated wheat straw. The results pointed out that pre-treated wheat straw prompted a more stable performance (in terms of pH and alkalinity) and an improved methane yield (128% increment) of the mesophilic codigestion process, in comparison to the "untreated" scenario. The pre-treatment increased the content of cellulose, hemicellulose and other compounds (waxes, pectin, oil, etc.) in the liquid fraction, from 5% to 60%, from 11.5% to 39.1% TS and from 57% to 79% of the TS in the liquid fraction for the untreated and pre-treated wheat straws, respectively. Finally, the pre-treated scenario gained an energy surplus of a factor 13.5 and achieved a positive net benefit of 90.4€tVS-WS-1d-1, being a favourable case for an eventual scale-up of the combined process.