Measurement of macrocyclic trichothecene in floor dust of water-damaged buildings using gas chromatography/tandem mass spectrometry-dust matrix effects.

Gas chromatography-tandem mass spectrometry (GC-MS/MS) was used to detect fungal secondary metabolites. Detection of verrucarol, the hydrolysis product of Stachybotrys chartarum macrocyclic trichothecene (MCT), was confounded by matrix effects associated with heterogeneous indoor environmental samples. In this study, we examined the role of dust matrix effects associated with GC-MS/MS to better quantify verrucarol in dust as a measure of total MCT. The efficiency of the internal standard (ISTD, 1,12-dodecanediol), and application of a matrix-matched standard correction method in measuring MCT in floor dust of water-damaged buildings was additionally examined. Compared to verrucarol, ISTD had substantially higher matrix effects in the dust extracts. The results of the ISTD evaluation showed that without ISTD adjustment, there was a 280% ion enhancement in the dust extracts compared to neat solvent. The recovery of verrucarol was 94% when the matrix-matched standard curve without the ISTD was used. Using traditional calibration curves with ISTD adjustment, none of the 21 dust samples collected from water damaged buildings were detectable. In contrast, when the matrix-matched calibration curves without ISTD adjustment were used, 38% of samples were detectable. The study results suggest that floor dust of water-damaged buildings may contain MCT. However, the measured levels of MCT in dust using the GC-MS/MS method could be significantly under- or overestimated, depending on the matrix effects, the inappropriate ISTD, or combination of the two. Our study further shows that the routine application of matrix-matched calibration may prove useful in obtaining accurate measurements of MCT in dust derived from damp indoor environments, while no isotopically labeled verrucarol is available.

Characterization of cleaning and disinfecting tasks and product use among hospital occupations.

BACKGROUND: Healthcare workers have an elevated prevalence of asthma and related symptoms associated with the use of cleaning/disinfecting products. The objective of this study was to identify and characterize cleaning/disinfecting tasks and products used among hospital occupations. METHODS: Workers from 14 occupations at five hospitals were monitored for 216 shifts, and work tasks and products used were recorded at five-minute intervals. The major chemical constituents of each product were identified from safety data sheets. RESULTS: Cleaning and disinfecting tasks were performed with a high frequency at least once per shift in many occupations. Medical equipment preparers, housekeepers, floor strippers/waxers, and endoscopy technicians spent on average 108-177 min/shift performing cleaning/disinfecting tasks. Many occupations used products containing amines and quaternary ammonium compounds for >100 min/shift. CONCLUSIONS: This analysis demonstrates that many occupations besides housekeeping incur exposures to cleaning/disinfecting products, albeit for different durations and using products containing different chemicals.

Exposure to volatile organic compounds in healthcare settings.

OBJECTIVES: To identify and summarise volatile organic compound (VOC) exposure profiles of healthcare occupations. METHODS: Personal (n=143) and mobile area (n=207) evacuated canisters were collected and analysed by a gas chromatograph/mass spectrometer to assess exposures to 14 VOCs among 14 healthcare occupations in five hospitals. Participants were volunteers identified by their supervisors. Summary statistics were calculated by occupation. Principal component analysis (PCA) was used to reduce the 14 analyte inputs to five orthogonal factors and identify occupations that were associated with these factors. Linear regressions were used to assess the association between personal and mobile area samples. RESULTS: Exposure profiles differed among occupations; ethanol had the highest geometric mean (GM) among nursing assistants (∼4900 and ∼1900 µg/m(3), personal and area), and 2-propanol had the highest GM among medical equipment preparers (∼4600 and ∼2000 µg/m(3), personal and area). The highest total personal VOC exposures were among nursing assistants (∼9200 µg/m(3)), licensed practical nurses (∼8700 µg/m(3)) and medical equipment preparers (∼7900 µg/m(3)). The influence of the PCA factors developed from personal exposure estimates varied by occupation, which enabled a comparative assessment of occupations. For example, factor 1, indicative of solvent use, was positively correlated with clinical laboratory and floor stripping/waxing occupations and tasks. Overall, a significant correlation was observed (r=0.88) between matched personal and mobile area samples, but varied considerably by analyte (r=0.23-0.64). CONCLUSIONS: Healthcare workers are exposed to a variety of chemicals that vary with the activities and products used during activities. These VOC profiles are useful for estimating exposures for occupational hazard ranking for industrial hygienists as well as epidemiological studies.

Serial evaluations at an indium-tin oxide production facility.

BACKGROUND: We evaluated the effectiveness of workplace changes to prevent indium lung disease, using 2002-2010 surveillance data collected by an indium-tin oxide production facility. METHODS: We assessed pulmonary function using lower limits of normal. Blood indium concentration and personal air sampling data were used to estimate exposure. RESULTS: Abnormalities were uncommon at hire. After hire, prevalence of spirometric restriction was 31% (n = 14/45), about fourfold higher than expected. Excessive decline in FEV1 was elevated at 29% (n = 12/41). Half (n = 21/42) had blood indium ≥5 µg/l. More recent hires had fewer abnormalities. There was a suggestion that abnormalities were more common among workers with blood indium ≥5 µg/l, but otherwise an exposure-response relationship was not evident. Peak dust concentrations were obscured by time averaging. CONCLUSIONS: Evolving lung function abnormalities consistent with subclinical indium lung disease appeared common and merit systematic investigation. Traditional measures of exposure and response were not illustrative, suggesting fresh approaches will be needed. Workplace changes seemed to have had a positive though incomplete impact; novel preventive interventions are warranted.

Indium lung disease.

BACKGROUND: Reports of pulmonary fibrosis, emphysema, and, more recently, pulmonary alveolar proteinosis (PAP) in indium workers suggested that workplace exposure to indium compounds caused several different lung diseases. METHODS: To better understand the pathogenesis and natural history of indium lung disease, a detailed, systematic, multidisciplinary analysis of clinical, histopathologic, radiologic, and epidemiologic data for all reported cases and workplaces was undertaken. RESULTS: Ten men (median age, 35 years) who produced, used, or reclaimed indium compounds were diagnosed with interstitial lung disease 4-13 years after first exposure (n = 7) or PAP 1-2 years after first exposure (n = 3). Common pulmonary histopathologic features in these patients included intraalveolar exudate typical of alveolar proteinosis (n = 9), cholesterol clefts and granulomas (n = 10), and fibrosis (n = 9). Two patients with interstitial lung disease had pneumothoraces. Lung disease progressed following cessation of exposure in most patients and was fatal in two. Radiographic data revealed that two patients with PAP subsequently developed fibrosis and one also developed emphysematous changes. Epidemiologic investigations demonstrated the potential for exposure to respirable particles and an excess of lung abnormalities among coworkers. CONCLUSIONS: Occupational exposure to indium compounds was associated with PAP, cholesterol ester crystals and granulomas, pulmonary fibrosis, emphysema, and pneumothoraces. The available evidence suggests exposure to indium compounds causes a novel lung disease that may begin with PAP and progress to include fibrosis and emphysema, and, in some cases, premature death. Prospective studies are needed to better define the natural history and prognosis of this emerging lung disease and identify effective prevention strategies.

Correcting diacetyl concentrations from air samples collected with NIOSH method 2557.

Diacetyl (2,3-butanedione), a diketone chemical used to impart a buttery taste in many flavoring mixtures, has been associated with bronchiolitis obliterans in several industrial settings. For workplace evaluations in 2000-2006, National Institute for Occupational Safety and Health (NIOSH) investigators used NIOSH Method 2557, a sampling and analytical method for airborne diacetyl utilizing carbon molecular sieve sorbent tubes. The method was subsequently suspected to progressively underestimate diacetyl concentrations with increasing sampling site humidity. Since underestimation of worker exposure may lead to overestimation of respiratory health risk in quantitative exposure-effect analyses, correction of the diacetyl concentrations previously reported with Method 2557 is essential. We studied the effects of humidity and sample storage duration on recovery of diacetyl from experimental air samples taken from a dynamically generated controlled test atmosphere that allowed control of diacetyl concentration, temperature, relative humidity, sampling duration, and sampling flow rate. Samples were analyzed with Method 2557, and results were compared with theoretical test atmosphere diacetyl concentration. After fitting nonlinear models to the experimental data, we found that absolute humidity, diacetyl concentration, and days of sample storage prior to extraction affected diacetyl recovery as did sampling flow rate to a much smaller extent. We derived a mathematical correction procedure to more accurately estimate historical workplace diacetyl concentration based on laboratory-reported concentrations of diacetyl using Method 2557, and sample site temperature and relative humidity (to calculate absolute humidity), as well as days of sample storage prior to extraction in the laboratory. With this correction procedure, quantitative risk assessment for diacetyl can proceed using corrected exposure levels for air samples previously collected and analyzed using NIOSH Method 2557 for airborne diacetyl.

Evaluation of the Limulus amebocyte lysate and recombinant factor C assays for assessment of airborne endotoxin.

As a potent inflammatory agent, endotoxin is a key analyte of interest for studies of lung ailments in domestic environments and occupational settings with organic dust. A relatively unexplored advance in endotoxin exposure assessment is the use of recombinant factor C (rFC) from the Limulus pathway in a fluorometric assay. In this study, we compared airborne endotoxin concentrations in laboratory- and field-collected parallel air samples using the kinetic Limulus amebocyte lysate (LAL) assay and the rFC assay. Air sampling was performed using paired Institute of Occupational Medicine (IOM) samplers, Button samplers, closed-face cassettes, and cyclone samplers. Field sampling was performed in 10 livestock production facilities, including those housing swine, chicken, turkey, dairy cows, cattle, and horses. Laboratory sampling was performed in exposure chambers using resuspended airborne dust collected in five livestock facilities. Paired samples were extracted in pyrogen-free water with 0.05% Tween 20 and analyzed using LAL and rFC assays. In 402 field sample pairs there was excellent agreement between endotoxin concentrations determined by LAL and rFC (r = 0.93; P < 0.0001). In 510 laboratory sample pairs there was also excellent agreement between the two assays (r = 0.86; P < 0.0001). Correlations for subgroups of facility or dust type ranged from 0.65 to 0.96. Mixed-model analysis of variance (ANOVA) for the field studies showed significant interactions of facility-sampler and facility-assay. rFC/LAL ratios of the geometric means were 0.9 to 1.14 for the samplers (not significantly different from 1.0). The data from this study demonstrate that the LAL assay and the rFC assay return similar estimates of exposure in livestock facilities. Both methods provided suitable lower limits of detection such that all but 19 of 1,824 samples were quantifiable.

Muramic acid, endotoxin, 3-hydroxy fatty acids, and ergosterol content explain monocyte and epithelial cell inflammatory responses to agricultural dusts.

In agricultural and other environments, inhalation of airborne microorganisms is linked to respiratory disease development. Bacterial endotoxins, peptidoglycans, and fungi are potential causative agents, but relative microbial characterization and inflammatory comparisons amongst agricultural dusts are not well described. The aim of this study was to determine the distribution of microbial endotoxin, 3-hydroxy fatty acids (3-OHFA), muramic acid, and ergosterol and evaluate inflammatory responses in human monocytes and bronchial epithelial cells with various dust samples. Settled surface dust was obtained from five environments: swine facility, dairy barn, grain elevator, domestic home (no pets), and domestic home with dog. Endotoxin concentration was determined by recombinant factor C (rFC). 3-OHFA, muramic acid, and ergosterol were measured using gas chromatography-mass spectrometry. Dust-induced inflammatory cytokine secretion in human monocytes and bronchial epithelial cells was evaluated. Endotoxin-independent dust-induced inflammatory responses were evaluated. Endotoxin and 3-OHFA levels were highest in agricultural dusts. Muramic acid, endotoxin, 3-OHFA, and ergosterol were detected in dusts samples. Muramic acid was highest in animal farming dusts. Ergosterol was most significant in grain elevator dust. Agricultural dusts induced monocyte tumor necrosis factor (TNF) alpha, interleukin (IL)-6, IL-8, and epithelial cell IL-6 and IL-8 secretion. Monocyte and epithelial IL-6 and IL-8 secretion was not dependent on endotoxin. House dust(s) induced monocyte TNFalpha, IL-6, and IL-8 secretion. Swine facility dust generally produced elevated responses compared to other dusts. Agricultural dusts are complex with significant microbial component contribution. Large animal farming dust(s)-induced inflammation is not entirely dependent on endotoxin. Addition of muramic acid to endotoxin in large animal farming environment monitoring is warranted.

Endotoxin exposure and inflammation markers among agricultural workers in Colorado and Nebraska.

The adverse respiratory effects of agricultural dust inhalation are mediated in part by endotoxin, a constituent of gram-negative bacterial cell walls. This study quantified personal work-shift exposures to inhalable dust, endotoxin, and its reactive 3-hydroxy fatty acid (3-OHFA) constituents among workers in grain elevators, cattle feedlots, dairies, and on corn farms. Exposures were compared with post-work-shift nasal lavage fluid inflammation markers and respiratory symptoms. Breathing-zone personal air monitoring was performed over one work shift to quantify inhalable dust (Institute of Medicine samplers), endotoxin (recombinant factor C [rFC] assay), and 3-OHFA (gas chromatography/mass spectrometry). Post-shift nasal lavage fluids were assayed for polymorphonuclear neutrophils (PMN), myeloperoxidase (MPO), interleukin 8 (IL-8), albumin, and eosinophilic cation protein (ECP) concentrations. The geometric mean (GSD) of endotoxin exposure (rFC assay) among the 125 male participants was 888 +/- (6.5) EU/m(3), and 93% exceeded the proposed exposure limit (50 EU/m(3)). Mean PMN, MPO, albumin, and ECP levels were two- to threefold higher among workers in the upper quartile of 3-OHFA exposure compared to the lowest exposure quartile. Even numbered 3-OHFA were most strongly associated with nasal inflammation. Symptom prevalence was not elevated among exposed workers, possibly due to endotoxin tolerance or a healthy worker effect in this population. This is the first study to evaluate the relationship between endotoxin's 3-OHFA constituents in agricultural dust and nasal airway inflammation. More research is needed to characterize the extent to which these agents contribute to respiratory disease among agricultural workers.

Recombinant factor C (rFC) assay and gas chromatography/mass spectrometry (GC/MS) analysis of endotoxin variability in four agricultural dusts.

Endotoxin exposure is a significant concern in agricultural environments due to relatively high exposure levels. The goals of this study were to determine patterns of 3-hydroxy fatty acid (3-OHFA) distribution in dusts from four types of agricultural environments (dairy, cattle feedlot, grain elevator, and corn farm) and to evaluate correlations between the results of gas chromatography/mass spectrometry (GC/MS) analysis (total endotoxin) and biological recombinant factor C (rFC) assay (free bioactive endotoxin). An existing GC/MS-MS method (for house dust) was modified to reduce sample handling and optimized for small amount (<1 mg) of agricultural dusts using GC/EI-MS. A total of 134 breathing zone samples using Institute of Occupational Medicine (IOM) inhalable samplers were collected from agricultural workers in Colorado and Nebraska. Livestock dusts contained approximately two times higher concentrations of 3-OHFAs than grain dusts. Patterns of 3-OHFA distribution and proportion of each individual 3-OHFA varied by dust type. The rank order of Pearson correlations between the biological rFC assay and the modified GC/EI-MS results was feedlot (0.72) > dairy (0.53) > corn farm (0.33) > grain elevator (0.11). In livestock environments, both odd- and even-numbered carbon chain length 3-OHFAs correlated with rFC assay response. The GC/EI-MS method should be especially useful for identification of specific 3-OHFAs for endotoxins from various agricultural environments and may provide useful information for evaluating the relationship between bacterial exposure and respiratory disease among agricultural workers.