Isopropanol and methylformate exposure in a foundry: exposure data and neurobehavioural measurements.

OBJECTIVES: The aim of this study was to determine the dose-effect relationship between solvent exposure and acute neurobehavioural effects at the worksite. METHODS: In a balanced design, ten workers in a Swiss foundry were monitored for 15 days at ten different times during work. Urine samples were taken in the morning and at the time of examination, and personal exposure to isopropanol and methylformate was measured with active samplers. Neurobehavioural tests such as postural balance (bipedal, bipedal blind, monopedal), simple reaction time and digit span of the Neurobehavioural Evaluation System (NES2) and a combined memory and reaction-time test, the combi-test, were performed. A rating of well-being, and the last consumption of alcohol, caffeine, nicotine and medication were reported. RESULTS: Average environmental concentrations of isopropanol were at 44 ppm ( +/- 16 ppm), and at 36 ppm (+/-21 ppm) for methylformate. Maximum values of personal exposure to isopropanol reached barely the maximal allowable concentration (MAC) value (400 ppm); the methylformate personal exposure of three workers exceeded the MAC value (100 ppm). Urine concentrations of methanol were high (3.1 +/- 2.3 mg/l in the morning, 7.8 +/- 4.9 mg/l after exposure) compared with the results of other studies; concentrations of isopropanol were rather low (0.88 +/- 0.73 mg/l after exposure). CONCLUSIONS: Nevertheless, between personal exposure and biomonitoring, linear correlation was found. Methylformate exposure correlated with methanol and formic acid concentration in the urine, and isopropanol exposure with its concentration in the urine. With the neurobehavioural tests used, no solvent effect in relation to the dose could be determined.

Experimental exposure to methylformate and its neurobehavioral effects.

OBJECTIVES: The aim of the study was to investigate the acute effects of experimental methylformate exposure on the nervous system. METHODS: In an exposure chamber, 20 subjects were exposed to methylformate at 100 ppm [Swiss maximum allowable concentration (MAC)] for 8 h. The same number of subjects with the same ages (between 20 and 30 years), gender and education level (university) were examined by the same procedure as a control group. The subjects did not know if they were exposed or not. Three times (morning, noon, evening) during these 8 h, mood [Profile of Mood States (POMS)], neurobehavioral performance (reaction, Stroop, nonverbal learning, determination, tracking; Wiener Test System), vision (visual acuity, contrast sensitivity, color sensitivity) and postural sway were tested. During an undemanding test (POMS) and a demanding performance task (determination test), pulse, electromyography (EMG) of the forehead and of the neck were recorded. In the morning and evening spirometry [forced vital capacity (FVC), forced one-second expiration volume (FEV), medium expiration flow (MEF) and peak expiration flow (PEF)] and the odor perception threshold were measured. RESULTS: In the evening, in the exposed group, fatigue was significantly increased and the EMG of the forehead during a demanding task showed a different development during exposure. The other tests showed no significant solvent effect, but 16 of 43 test parameters showed a significant effect of time. CONCLUSIONS: The results of this study indicate a possible effect of methylformate exposure on the subjective feeling of fatigue after 8 h exposure at 100 ppm in young and healthy subjects, without measurable impairment of neurobehavioral performance. We assume that a similar effect in normal work, combined with a heavy workload and shift work, can lead to an impairment of productivity, and increase the risk of accidents.

Urinary methanol and formic acid as indicators of occupational exposure to methyl formate.

OBJECTIVE: To evaluate the validity of methanol (MeOH) and formic acid (FA) in urine as biological indicators of methyl formate (MF) exposure in experimental and field situations. METHODS: The subjects were 28 foundrymen and two groups of volunteers (20 control and 20 exposed). Exposure assessment of the workers was performed by personal air and biological monitoring. Methyl formate vapour collected on charcoal tube was analysed by gas chromatography. The concentration of MF in the exposure chamber (volunteer-study) was monitored by two independent methods [flame ionisation detection (FID) and Fourier transformation infra-red detection (FTIR)]. Urinary metabolites (MeOH and FA) were analysed separately by headspace gas chromatography. RESULTS: The volunteers exposed to 100 ppm MF vapour at rest for 8 h excreted 3.62 +/- 1.13 mg MeOH/l (mean +/- SD) at the end of the exposure. This was statistically different (P < 0.001) from pre-exposure MeOH excretion (2.15 +/- 0.80 mg/1), or from that of controls (1.69 +/- 0.48 mg/l). The urinary FA excretion was 32.2 +/- 11.3 mg/g creatinine after the exposure, which was statistically different (P < 0.001) from pre-exposure excretion (18.0 +/- 9.3 mg/g creatinine) or that of controls (13.8 +/- 7.9 mg/g creatinine). In foundrymen, the urinary FA excretion after the 8 h workshift exposure to a time weighted average (TWA) concentration of 2 to 156 ppm MF showed a dose-dependent increase best modelled by a polynomial function. The highest urinary FA concentration was 129 mg/g creatinine. The pre-shift urinary FA of the foundrymen (18.3 +/- 5.6 mg/g creatinine) did not differ from that of controls (13.8 +/- 7.9 mg/g creatinine). The urinary MeOH excretion of the foundrymen after the shift, varied from < 1 to 15.4 mg/l, while the correlation with the preceding MF exposure was poor. The foundrymen excreted more (P = 0.01) FA (2.12 +/- 3.56 mg/g creatinine) after the workshift than experimentally, once-exposed volunteers (0.32 +/- 0.11 mg/g creatinine) at a similar inhaled MF level of 1 ppm). CONCLUSIONS: In spite of its high background level in non-exposed subjects, urinary FA seems to be a useful biomarker of methyl formate exposure. The question remains as to what is the reason for the differences in chronic and acute exposure respectively.

Neurobehavioural effects of experimental isopropanol exposure.

OBJECTIVES: The study investigated the acute effects of isopropanol exposure at the maximum allowable concentration (MAC) level on the performance of neurobehavioural functions. METHODS: In an exposure chamber 20 healthy subjects aged between 21 and 30 years were exposed to isopropanol at a concentration of 400 ppm (Swiss MAC value) for 8 h. A control group of another 20 subjects of the same age range, gender and education as used in a previous study with methylformate were subjected to the same test procedures without exposure. Mood was measured with the profile of mood states (POMS) in the morning, at noon and in the evening. Neurobehavioural performance tests were administered using the Wiener Test System (Wiener reaction test, Stroop, nonverbal learning, Wiener determination test, "Konturtracking" test), and the digit span test of the Neurobehavioural evaluation system (NES2). A test for postural sway was also conducted. During the POMS and the Wiener determination test the electromyography of the forehead and the left neck muscle as well as the pulse were registered. In the morning and evening spirometry (FVC, FEV, MEF and PEF) and odour threshold were measured. RESULTS: Only postural sway in bipedal standing at noon showed stronger deterioration in the exposed than in the control group when compared with the morning values. The evening values of monopedal standing were also more impaired in the exposed than the control group. In the other tests, no solvent effect could be established. CONCLUSIONS: It can be assumed, that, similar to other alcohols, isopropanol affects postural balance. Our results point to such a disturbance, but because it is the only study so far using the MAC value, any conclusions about safety risks would be premature.