Engineering processes in meat products and how they influence their biophysical properties.

Food engineering aspects of cooking of meat products in relation to their biophysical properties, such as water- and fat-holding, have been reviewed. Moreover, some of the new emerging, mild cooking technologies, such as high pressure and electro-based heating (radio frequency cooking and ohmic heating) have been discussed in relation to the biophysical properties of the meat products treated. The holding of the bulk water (about 70% of the muscle weight) was discussed, arguing capillary forces to be one of the dominating mechanisms for this holding, whereas the losses of water and fat (the flow) within the meat are governed by Darcy's law. If we compare the fat-holding in beef burgers and emulsion sausages (frankfurter type) beef burgers lose much larger part of the fat than the emulsion sausages and for the former the fat losses increase with fat content. For emulsion sausages, however, fat losses are independent of fat content and the properties of the fat and the protein matrix are more interrelated. It has been shown experimentally during double sided pan frying of beef burgers that the pressure driven water loss (up to 80% of the water loss) is a substantially more important mechanism governing the water loss than the evaporation losses occurring at the surface crust. Fat losses increased significantly with fat content and were not influenced to any large extent by the cooking temperature and were in the form of drip. By using processing technologies such as high pressure and/or electro-based heating (radio frequency cooking and ohmic heating) a more homogenous heating can be achieved, the reason being volumetric heating. In comparison with conventional heating shorter cooking times were obtained and with smaller temperature gradients lower water- and fat-losses occurred and the yield can be substantially improved. High pressure processing (100-1000MPa) is a preservation technology that allows the reduction of the microbial load at low or moderate temperature. The highest potential application for meat products might be to pressurise finally sealed packages of contaminated sliced high value salami and ham products as the colour of those products can resist high pressure. Ohmic heating is based on the passage of electrical current through a food product having an electrical resistance. For radio-frequency (RF) cooking and micro-wave heating the food product forms a dielectric media between the two electrodes and the heating is caused by the internal friction of the polar molecules. The used frequencies for RF-cooking are lower in the MHz range than for micro-wave heating being in the GHz range.

Effects of heat on meat proteins - Implications on structure and quality of meat products.

Globular and fibrous proteins are compared with regard to structural behaviour on heating, where the former expands and the latter contracts. The meat protein composition and structure is briefly described. The behaviour of the different meat proteins on heating is discussed. Most of the sarcoplasmic proteins aggregate between 40 and 60 °C, but for some of them the coagulation can extend up to 90°C. For myofibrillar proteins in solution unfolding starts at 30-32°C, followed by protein-protein association at 36-40°C and subsequent gelation at 45-50°C (conc.>0.5% by weight). At temperatures between 53 and 63°C the collagen denaturation occurs, followed by collagen fibre shrinkage. If the collagen fibres are not stabilised by heat-resistant intermolecular bonds, it dissolves and forms gelatine on further heating. The structural changes on cooking in whole meat and comminuted meat products, and the alterations in water-holding and texture of the meat product that it leads to, are then discussed.

Contribution of pigment content, myoglobin forms and internal reflectance to the colour of pork loin and ham from pure breed pigs.

The colour of loin, M. longissimus dorsi (LD), and ham, M. biceps femoris (BF), from pure breed Hampshire, Swedish Landrace and Swedish Yorkshire pigs was studied. The contribution of the pigment content, the myoglobin forms deoxymyoglobin (Mb), oxymyoglobin (MbO) and metmyoglobin (MetMb) and the internal reflectance to the colour of pork of normal meat quality was evaluated using partial least squares regression (PLS). The colour of LD and BF from the Hampshire breed was more red and yellow and more saturated than the colour of the same muscles from the Swedish Landrace and the Swedish Yorkshire breeds. Furthermore, BF from Hampshire was darker than BF from the other two breeds. These differences in colour were related to the lower pH in Hampshire, resulting in more blooming and in higher internal reflectance, and to the higher pigment content. The colour of BF was darker and more red than the colour of LD within each breed. No colour difference was found between gilts and castrates within each breed. Most of the variation (86-90%) in lightness (L* value), redness (a* value) and yellowness (b* value), chroma (saturation) and hue angle of pork of normal meat quality was explained by the pigment content, myoglobin forms and internal reflectance. The L* value, a* value, chroma and hue angle were influenced by both the pigment content and by the myoglobin forms to almost the same extent, while the internal reflectance was of no significance to these colour parameters. The b* value was influenced most by the myoglobin forms, less by the internal reflectance and almost not at all by the pigment content.

An international study on the importance of androstenone and skatole for boar taint: I. Presentation of the programme and measurement of boar taint compounds with different analytical procedures.

An international study, involving 11 participants in 7 European countries, was conducted to provide scientific evidence for an objective measurement of boar taint in entire male pigs and its possible variation between countries. The specific objectives were to determine the respective contributions of androstenone and skatole to boar taint and their possible variations according to production systems and consumer populations. Over 4000 entire male pigs and 200 gilts were raised and slaughtered in 6 countries. Meat samples were taken from the loin and backfat samples were used for the rapid measurement of androstenone and skatole. A sub-population of 377 entire males and 42 gilts was then selected in such a way as to represent all combinations of skatole and androstenone levels. Androstenone and skatole levels in the selected samples were checked, using established reference methods. Meat samples from the selected animals were used for sensory evaluation by trained panels and for consumer surveys in 7 European countries. The present paper gives a general presentation of the programme and reports the main characteristics of the samples. Three companion papers present the results of the evaluation by trained sensory panels [Dijksterhuis, G., Engel, B., Walstra, P., Font i Furnols, M., Agerhem, H., Fisher, K., Oliver, M. A., Claudi-Magnussen, C., Siret, F., Béague, M. P., Homer, D. B., & Bonneau, M. (2000). An international study on the importance of androstenone and skatole for boar taint: II. Sensory evaluation by trained panels in seven European countries. Meat Science54, 261-269], the results of the consumer surveys [Matthews, K. R., Homer, D. B., Punter, P., Béague, M. P., Gispert, M., Kemspter, A. J., Agerhem, H., Claudi-Magnussen, C., Fischer, K., Siret, F., Leask, H., Font i Furnols, M., & Bonneau, M. (2000). An international study on the importance of androstenone and skatole for boar taint: III. Consumer survey in seven European countries. Meat Science, 54, 271-283] and the main conclusions and recommendations [Bonneau, M., Walstra, P., Claudi-Magnussen, C., Kempster, A. J., Tornberg, E., Fischer, K., Diestre, A., Siret, F., Chevillon, P., Claus, R., Dijksterhuis, G., Punter, P., Matthews, K. R., Agerhem, H., Béague, M. P., Oliver, M. A., Gispert, M., Weiler, U., von Seth, G., Leask, H., Font i Furnols, M., Homer, D. B., & Cook, G. L. (2000). An international study on the importance of androstenone and skatole for boar taint: IV. Simulation studies on consumer dissatisfaction with entire male pork and the effect of sorting out carcasses on the slaughter line, main conclusions and recommendations. Meat Science, 54, 285-295]. Seasonal effects and differences between countries in skatole and androstenone levels are presented elsewhere [Walstra, P., Claudi-Magnussen, C., Chevillon, P., von-Seth, G., Diestre, A., Matthews, K. R., Homer, D. B., & Bonneau, M. (in press). An international study on the importance of androstenone and skatole for boar taint: Levels of androstenone and skatole according to country and season. Livestock Production Science]. A supplementary paper considers the effects of human sensitivity to androstenone and skatole on the consumer acceptance of entire male pork [Weiler, U., Font i Furnols, M., Fischer, K., Kemmer, H., Oliver, M. A., Gispert, M., Dobrowolski, A., & Claus, R. (in press). Influence of differences in sensitivity of Spanish and German consumers to perceive androstenone on the acceptance of boar meat differing in skatole and androstenone concentrations. Meat Science]. A study of possible other compounds contributing to boar taint was also carried out within this programme.

An international study on the importance of androstenone and skatole for boar taint: IV. Simulation studies on consumer dissatisfaction with entire male pork and the effect of sorting carcasses on the slaughter line, main conclusions and recommendations.

An international study has been conducted in order to determine the respective contributions of androstenone and skatole to boar taint and their possible variations according to production systems and consumer populations. The presentation of the study and the main results concerning skatole and androstenone levels and data from sensory evaluation or consumer surveys are reported in companion papers. The present paper summarises the main conclusions of the study and gives tentative recommendations. A simulation study was conducted, based on the skatole and androstenone levels currently observed in European populations of entire male pigs and on the results of the consumer surveys. The first part of the simulation study demonstrated that, overall, 6.5% (odour) and 3.0% (flavour) more consumers were dissatisfied with entire male than with gilt pork. The differences were, however, very variable according to countries. Consumer dissatisfaction for the odour of entire male pork was mostly associated with high skatole levels, while androstenone had little influence on it. On the other hand, androstenone and skatole had similar contributions to the level of dissatisfaction for flavour. From the present study it is not possible to determine clear cut-off levels for androstenone/skatole. The regression equations presented in [Matthews, K. R., Homer, D. B., Punter, P., Béague, M. P., Gispert, M., Siret, F., Leask, H., Fonti i Furnols, M., & Bonneau, M. (2000). An international study on the importance of androstenone, skatole for boar taint: III. Consumer survey in seven European countries. Meat Science, 54, 271-283] provide a basis for decision making. However, due to methodological limitations, the results may underestimate consumer reaction to entire male pork. The second part of the simulation study demonstrated that sorting carcasses on the basis of androstenone/skatole would reduce, but not eliminate, differences in consumer dissatisfaction between entire male and gilt pork. For odour, taking androstenone into account did not improve the efficiency obtained from sorting using skatole only. For flavour, sorting using both compounds was more efficient than sorting using skatole only. Sorting out 15% of the entire males, on the basis of skatole only, would result in a difference in the proportion of dissatisfied consumers of 4.2% (odour) or 2.0% (flavour) between entire male and gilt pork. The results of the last part of the simulation study demonstrated that decreasing skatole in entire male pig populations, to levels as low as 0.10 ppm, would still result in a difference in the proportion of dissatisfied consumers of 3.2% (odour) or 1.6% (flavour). To reduce this difference further, the levels of both compounds would have to be reduced still further. The lowest difference that can be achieved is 2.3% (odour) or 0.4% (flavour). The conclusions of the present study may differ according to whether immediate commercial applications or long-term goals are considered. On the basis of the skatole and androstenone levels currently observed in entire male pig populations, sorting out procedures based on skatole is the easiest way to rapidly achieve a significant decrease in consumer dissatisfaction with entire male pork. In most countries, however, this will not be sufficient to obtain the same level of acceptability as with gilts. In the long term, a sharp reduction in both skatole and androstenone would have to be achieved in entire male pig populations to obtain low differences in acceptability between entire male and gilt pork.

Prediction of water-holding capacity and composition of porcine meat by comparative spectroscopy.

Four spectroscopic instruments, a fibre optical probe (FOP), a visual (VIS) and near infrared (NIR) reflectance spectrophotometer, a reflectance spectrofluorometer and a low-field (1)H nuclear magnetic resonance (LF-NMR) instrument were used to perform measurements on two muscles (longissimus dorsi and semitendinosous) from 39 pigs, 18 of which were carriers of the Halothane gene. Water-holding capacity (drip loss and filter paper wetness) and chemical composition (intramuscular fat and water) of the muscle samples were determined for spectroscopic calibration. Prediction models were established by partial least squares regression to evaluate the potential of using the spectroscopic techniques in an on-line slaughterhouse system. VIS data gave good prediction models, indicating that current industrial colour systems can be advanced into more specific meat evaluation systems by including the entire visible spectral range. The FOP and fluorescence measurements were less successful, and suffered from sampling problems since they measure only a small area. The best regression models were obtained from LF-NMR data for all reference quality measures and yielded a correlation coefficient of 0.75 with drip loss. LF-NMR proved able to distinguish between the two muscles and the results for their longitudinal relaxation times, T(21), were proportional to their average myofibrillar cross-sectional areas reported in the literature.

Determination of RN(-) phenotype in pigs at slaughter-line using visual and near-infrared spectroscopy.

The specific characteristics of meat from the Hampshire breed of pig, including high glycogen content and low ultimate pH and technological yield, have been associated with the dominant RN gene. In Sweden, purebred Hampshire or Hampshire x Yorkshire is often used as terminal sire in the three-way crosses used for pig meat production. For the industry producing cured and cooked hams there is a need to detect the RN(-) carriers of the pigs early post mortem in order to select non-carriers for ham production. In the present study, the possibility of separating RN(-) carriers from non-carriers using a combination of visual and near-infrared (NIR) spectroscopic measurements in reflectance mode through a fibre-optic probe has been studied on commercial pigs in a slaughterhouse. The NIR measurements were performed 30 min post-mortem. Sixty-three animals were considered to be carriers and 33 animals non-carriers based on their glycolytic potential in M. semimembranosus (above 200 µmol/g for RN(-)rn(+) and below 180 µmol/g for rn(+)rn(+)). By using NIR together with classification with neural networks, RN(-) carriers could be separated from non-carriers. None of the carriers and only four non-carriers of the RN gene were misclassified as carriers of the RN gene. The ultimate pH could be predicted using linear partial least squares regression with a correlation coefficient of 0.57 and an accuracy of 0.074 root mean square error of prediction.

Effect of rigor temperature on muscle shortening and tenderisation of restrained and unrestrained beef m. longissimus thoracicus et lumborum.

Pairs of muscularis longissimus thoracicus et lumborum (LTL) from young bulls were removed within 1h of slaughter. Small portions of the muscles were placed in a rigormeter to continously follow the isometric tension and isotonic shortening developed, at constant temperatures of 15, 20, 25, 30 and 35°C, as the muscle went into rigor. The bulk LTL was placed in water baths at the same temperature. One of the bulk pairs was tightly restrained by wrapping, to reduce muscle shortening, the other was unrestrained free to shorten. For the bulk samples, shear values were measured using a Warner-Bratzler instrument (1, 7 and 14 days post mortem), and sensory attributes were measured using a sensory panel (7 and 14 days post mortem). Minimum tension and shortening occurred at 15°C. The activation energy for the muscle shortening process was larger than for the isometric tension process. This indicates that the isometric tension data, collected during rigor, does not solely reflect muscle shortening. Thus, a counteracting process that decreases the tension response, most likely ageing is simultaneously detected. Meat that went into rigor at 15°C had least shortening and was always more tender than meat going into rigor at higher temperatures. For meat entering rigor at temperatures higher than 15°C, restraining of the muscle by wrapping, significantly (p<0.05) decreased the amount of muscle shortening and resulted in an improved meat tenderness (p<0.001). It was also observed that at rigor temperatures higher than 15°C the meat tenderness is affected negatively by a reduced ageing capacity. It therefore appears that muscle shortening and enzyme activity both affect tenderness and that both are highly affected by rigor temperature and have the greatest beneficial effect at a rigor temperature of 15°C.

Sensory and technological meat quality in carriers and non-carriers of the RN(-) allele in Hampshire crosses and in purebred Yorkshire pigs.

The effect of the dominant RN(-) allele on technological and sensory meat quality of loin and ham from pigs, crossbred from Landrace × Yorkshire sows and one Hampshire sire heterozygous for the RN(-) allele was studied. The non-carriers of the RN(-) allele and the purebred Yorkshire pigs were similar regarding most of the technological traits. In comparison with the RN(-) carriers, they had higher values for pH(u), Napole yield, dry matter and protein content, but lower values for drip loss, filter paper wetness, cooking loss, internal reflectance, residual glycogen and glycolytic potential. The three groups did not differ concerning lactate content, intramuscular fat or ash content. Shear-force values did not differ between the two RN genotypes, but both genotypes had lower shear-force values than the purebred Yorkshire pigs. Non-carriers had higher processing yield for cured cooked ham than RN(-) carriers. The RN(-) allele had little effect on the sensory attributes, as assessed by a trained panel using a descriptive test, but there was a tendency to lower chewing time for meat from the crossbreds compared to the purebred Swedish Yorkshire. RN(-) carriers produced more acidic fresh loin than non-carriers and purebred Yorkshire pigs, and juicier cured cooked ham than non-carriers.

[Occurrence of hepatitis A infection in Denmark]. / Forekomst af hepatitis A-infektion i Danmark.

Hepatitis A is a mandatory notifiable disease in Denmark. The number of notified cases of hepatitis A was compiled over a period of 16 years, 1980-1995. A total of 3790 were included in the study. The average incidence was 4.6 per 100,000 population per year, but the number of cases declined slightly through the period. Median age among Danes were 27 years and among immigrants seven years. The male to female ratio was 1.5 among Danes and 1.1 among foreigners. The incidence was highest in the capital area. Two-thirds of the notified persons were infected in Denmark, among whom the source of infection was unknown for half of the cases. The two most important sources of infection were household contracts and i.v. drug abuse. A total of 73 persons were infected in connection with their occupation in Denmark. Workers in day care centres, sewage workers and cleaners may be particularly at risk, although the risk is still low. The relevance of vaccination recommendations for special groups is considered.

Biophysical aspects of meat tenderness.

Biophysical aspects of meat tenderness is reviewed, where the meat structural origin of variation in meat tenderness is tried to be elucidated. Processes, such as rigor development and ageing, known to influence the properties of the structural components, is covered, and variables that influence those processes, such as chilling, electrical stimulation and stress ante-mortem, are discussed. Meat tenderness can be evaluated both by sensory and instrumental methods. The relationships between mechanical and sensory assessments tend to be non-linear, which can be due to non-linearity in the sensory evaluation and that muscle fibre orientation is easier to control in instrumental than in sensory evaluation. Structural changes of the meat occuring during rigor development are both longitudinal and lateral contraction of the myofibrillar mass. Other structural events, based on the proteolytic action, are the loosing up of the myofibrils held together laterally, weakening of the myofibrillar length and myofibril fragmentation. Using instrumental recordings of meat toughness (Warner-Bratzler (W-B) peak force), it decreases significantly with degree of contraction, when raw, but the reverse is found, when meat is cooked above 60 °C. A structural explanation to this behaviour is suggested to be the following. When meat is raw the lateral contraction of the meat fiber increases with shorter sarcomeres, giving rise to a larger viscous component and hence a lower W-B peak force. On heating, however, with a larger extracellular space, when shortened, there is more room for the connective tissue to contract without being restricted by the myofibrillar mass. This in turn gives a higher number of fibers per unit cross-sectional area, hence a larger elastic modulus and a higher W-B peak force, when cooked. When chilling of muscle during rigor both warm- and cold-shortening occur. Minimal shortening region is for beef M. longissimus dorsi (LD) 10-15 °C and for M. semimembranosus (SM) 7-13 °C. For the SM muscle there is a high correlation between percentage shortening and ultimate tenderness both in the warm- and cold-shortening region. But for the LD muscle this is only the case in the cold-shortening region. This observation suggests that the LD muscle is a more enzymatically active muscle than SM. The influence of low-voltage electrical stimulation (ES) was followed in the cold-shortening region for muscles LD and SM. A significant effect on tenderness 15 days post-mortem was only observed for LD at 1 °C and 4 °C, but not for SM. It was suggested that enhanced proteolysis could be the reason for the improved tenderness on ES of LD, as colds-hortening was not prevented by ES. Long-term and short-term stress ante-mortem can give rise to DFD (dark, firm and dry)-and PSE (pale, soft and exudative)-meat, respectively. DFD-meat (pH(u) > 6.0 in LD) has relatively short sarcomere lengths, but still it is swollen laterally and has consequently a small extracellular space. Therefore DFD-meat usually is tender. PSE-meat has a large variation in sarcomere length. The long sarcomeres of PSE-meat is suggested to be caused by reduced shortening, due to the denaturation of the sarcoplasmic proteins during rigor. The short sarcomeres can be caused by a higher percentage of rigor development in the warm-shortening region and that the denaturation of the myosin heads cause both longitudinal and lateral contraction of the myofibrillar mass. There is also a large variation in tenderness of PSE-meat, but it has been found that this variation is positively correlated to the sarcomere length (r = 0.52**), as has been shown for the other variables that governs the rigor process.

The influence of low temperature, type of muscle and electrical stimulation on the course of rigor mortis, ageing and tenderness of beef muscles.

The course of rigor mortis, ageing and tenderness have been evaluated for two beef muscles, M. semimembranosus (SM) and M. longissimus dorsi (LD), when entering rigor at constant temperatures in the cold-shortening region (1, 4, 7 and 10°C). The influence of electrical stimulation (ES) was also examined. Post-mortem changes were registered by shortening and isometric tension and by following the decline of pH, ATP and creatine phosphate. The effect of ageing on tenderness was recorded by measuring shear-force (2, 8 and 15 days post mortem) and the sensory properties were assessed 15 days post mortem. It was found that shortening increased with decreasing temperature, resulting in decreased tenderness. Tenderness for LD, but not for SM, was improved by ES at 1 and 4°C, whereas ES did not give rise to any decrease in the degree of shortening during rigor mortis development. This suggests that ES influences tenderization more than it prevents cold-shortening. The samples with a pre-rigor mortis temperature of 1°C could not be tenderized, when stored up to 15 days, whereas this was the case for the muscles entering rigor mortis at the other higher temperatures. The results show that under the conditions used in this study, the course of rigor mortis is more important for the ultimate tenderness than the course of ageing.

The effect of high post-mortem temperature on the development of pale, soft and exudative pork: Interaction with ultimate pH.

The effects of post-mortem temperature and ultimate pH (pH(u), 24 h post mortem) on the development of the pale, soft and exudative (PSE) characteristics in pig longissimus dorsi muscle were studied. Ten out of the 13 pigs used received pre-slaughter injections of adrenaline in order to deplete muscle glycogen stores. The two muscles from each pig were held at 12 or 35°C during rigor mortis development. Results from covariance analysis, using pH(u) as covariate, showed that a high temperature (35°C) resulted in a dramatic increase in internal light scattering (FOP) 24 h post mortem and a significant decrease in water- and salt-soluble proteins. Cooking loss, sarcomere length and drip loss did not vary significantly with rigor temperature. Interaction between temperature and pH(u) was estimated by assessing the relationship between pH(u) and the difference between the two rigor temperatures for selected traits. The best predictive model was a segmented quadratic model with a plateau which gave significant results for FOP, drip loss, water- and salt-soluble proteins. The effect of temperature decreased curvilinearly when pH increased until a constant value above which no noticeable difference was recorded (drip loss, water- and salt-soluble proteins) or a constant difference was reached (FOP). The pH values corresponding to the convergence points differed from one trait to another. They ranged from 5·72 to 6·22. These results illustrate the importance of muscle glycogen content at slaughter and subsequent pH(u) with regard to the development of temperature-induced PSE meat.

The influence of high post-mortem temperature and differing ultimate pH on the course of rigor and ageing in pig Longissimus dorsi muscle.

This study was performed in order to assess the effect of temperature and differing ultimate pH (pH(u), 24 h post mortem) on the development of rigor mortis in pig Longissimus dorsi muscle. The rigor development (isometric tension and shortening) was measured continuously during the first 24 h post mortem, using an apparatus wherein muscle strips were held at constant temperatures of 12 or 35°C. pH(u) was manipulated by adrenaline injections preslaughter. The rates of pH fall, adenosine triphosphate (ATP) and creatine phosphate (CP) breakdown were markedly increased at 35°C compared to 12°C. For both temperatures, no delay phase was observed with regard to the development of shortening. Rigor resulted in higher maximum isometric tension and shortening and in shorter time needed to reach maximum values at 35°C than at 12°C. The results are discussed in connection with pH, ATP and CP data. The extent of ageing from 2 to 4 days post mortem, estimated through myofibrillar length determinations, was higher for 12°C than for 35°C. pH(u) affected significantly most of the traits under study, but its effect depended in some cases upon the rigor temperature. At 12°C, the traits related to the kinetics of rigor development were significantly affected by pH(u), but this was not the case at 35°C. Maximum isometric tension was significantly related to pH(u) at 35°C (r = 0·86, P < 0·001), but such a relationship was not found at 12°C. Myofibrillar lengths were significantly affected by pH(u), but in an opposite manner from one temperature to another. A positive relationship was found at 12°C and a negative one at 35°C. These results illustrate the importance of the interaction between the extent of pH fall and temperature with regard to post-mortem changes in pig muscle.

The influence of high temperature, type of muscle and electrical stimulation on the course of rigor, ageing and tenderness of beef muscles.

The course of rigor mortis (rigor), ageing and tenderness has been evaluated for three beef muscles; M. biceps femoris (BF), M. semimembranosus (SM) and M. semitendinosus (ST), when entering rigor at constant temperatures of 15 and 37°C respectively, with and without electrical stimulation (ES/NS) (85 V, 14 Hz and 32 s). The course of post-mortem changes has been registered by isometric tension, by shortening of unrestrained muscle strips and by following the pH decline and the changes in metabolites, such as ATP and CP. Ageing at +4°C was recorded by measuring Warner-Bratzler (W-B) shear values 2, 8 and 15 days post mortem. On the last occasion, the sensory properties of the cooked meat were also evaluated. Maximum shortening and isometric tension were higher at 37°C as compared to 15°C, whereas ES did not reduce rigor shortening. A high correlation between maximum shortening and the ATP-level at the onset of the shortening rapid phase was found (r = 0·77(∗∗∗)), which could explain the greater shortening obtained at 37°C compared to 15°C. Rigor shortening is an important phenomenon governing meat tenderness as tenderness is highly affected by rigor temperature but not by ES. This was the case for muscles SM and ST but not for BF muscle. Even though tenderness was measured after ageing (15 days post mortem), shortening during rigor seems to be more important for toughness when rigor mortis occurs at 37°C than any suggested tenderizing effect due to increased proteolysis in this temperature region.

Effect of time between adrenaline injection and slaughter on the rate and extent of post-mortem metabolism in porcine skeletal muscle.

The aim of this work was to study the effect of time between adrenaline injection and slaughter on the rate and extent of post-mortem metabolism in pig muscle. Five pigs were subcutaneously injected with adrenaline (0·3 mg/kg) or with a saline solution 4 h, 1 h or 15 min prior to slaughter. pH(1), pH(u) and FOP(u) were measured in Longissimus dorsi (LD) and Biceps femoris (BF) muscles. m.LD samples were taken 20 days before slaughter using biopsy sampling, immediately after bleeding and 45 min post mortem for biochemical analysis. m.LD glycolytic potential (very close to glycogen content) was decreased by the injection of adrenaline 4 h and 1 h prior to slaughter, when comparing values at rest (20 days before slaughter) and values determined immediately after bleeding. The depletion was greater fro the injection performed 4 h before slaughter. In this group pH(u) was higher foe adrenaline-injected pigs (5·69 versus 5·47 for pigs injected with saline solution) but the difference was not significant. Pigs injected with adrenaline 1 h prior to slaughter exhibited higher glucose, glucose-6-phosphate and lactate levels immediately after slaughter, lower pH(1) and higher FOP values in m.LD than control pigs. Since the differences in pH(1) were not explained by differences in the rate of build-up of lactate, it was hypothesized that pigs injected with adrenaline 1 h prior to slaughter had lower muscle pH at slaughter. It was concluded that the rate or the extent of post mortem metabolism in pig muscle may be affected independently, by manipulating the time between adrenaline injection and slaughter.

The variation in pig muscle glycolytic potential during lairage-an in-vivo study.

The variations in glycolytic potential (GP, very close to glycogen content) were studied during lairage in pig m. longissimus dorsi using biopsy sampling. Pigs were sampled on arrival at the abattoor and after treatment. Post-mortem measurements including pH(1), pH(u) and FOP(u) were performed on both longissimus dorsi (LD) and biceps femoris (BF) muscles. The animals underwent one of the following treatments: 2 h lairage mixed or unmixed; 24 h lairage mixed or unmixed with access to water only; 24 h lairage mixed or unmixed with access to a sugar solution. A significant depletion in GP occurred during lairage except when pigs were fed liquid sugar. The extent of this depletion was irrespective of lairage duration or mixing. Pigs lairaged 24 h with access to water only exhibited a significantly lower pH(1) in m. BF suggesting a higher propensity to develop PSE meat. Values of pH(u) were low (pH < 5·5), and did not vary significantly between the treatments since muscle GP remained high, despite the depletion induced by lairage. This was attributed to the high level of muscle glycogen characterizing the Hampshire crossbred pigs used in this experiment. These results suggest that interaction between breed and handling procedure may be important regarding meat pH(u).

Water distribution in porcine M. longissimus dorsi in relation to sensory properties.

The water distribution in M. longissimus dorsi (LD) from purebred Hampshire and Swedish Yorkshire pigs was recorded by proton-pulse-NMR. Three domains of water were seen with this type of method, designated as free, extracellular and intracellular water, respectively. The relative proton population for the free water increased from 1·8% in raw, to 3·3% in fried, samples from Hampshire and to 4·2% for the Yorkshire samples. The relaxation time of the extracellular water increased for Hampshire samples from 100 ms, when raw, to 108 ms and 114 ms for samples fried to centre temperatures of 68°C and 80°C, respectively. For Yorkshire samples it decreased from 122 to 108 and 109 ms, respectively. The relative proton population of the extracellular water decreased after frying (raw: 24·5%, 68°C: 18·6% and 80°C: 13·9%) for Hampshire samples, whereas the corresponding populations of protons for those of Yorkshire were 16·5%, 19·2% and 16·6%. The intracellular water had relaxation times of about 40 ms (raw), 30 ms (68°C) and 28 ms (80°C) for both breeds. The relative proton populations were: for Hampshire, 74·1% (raw), 77·7% (68°C), 83·4% (80°C) and, for Yorkshire, 81·6% (raw), 75·5% (68°C) and 77·2% (80°C). On average, the samples of Hampshire were more juicy and tender than those of Yorkshire. The sensory properties were related to the water distribution, but obvious influences of breed and end-point temperature at frying were noted for the relationships. In general, the juiciness and tenderness of fried LD samples could fairly well be predicted by the water distribution in raw meat. However, due to the influence of breed and temperature, different variables are best for the prediction. Also, when the sensory properties were related to the water distribution in fried samples, the influences of breed and end-point temperatures were noted.

Post-mortem energy metabolism in bovine muscles studied by non-invasive phosphorus-31 nuclear magnetic resonance.

Phosphorus-31 Nuclear Magnetic Resonance ((31)P-NMR) has been utilized to follow non-invasively the post-mortem metabolism of the major phosphorylated metabolites in muscles from beef slaughter carcasses. In addition to adenosine-5'-triphosphate (ATP), creatine phosphate (CP) and inorganic phosphate (P(i)) considerable amounts of glucose- and fructose-6-phosphate (G6P and F6P, respectively) as well as glycerol-3-phosphate (Glyc3P) were detected. ATP was mainly present as a Mg(2+)-ATP complex. Adenosine-5'-diphosphate (ADP) appeared to be mainly bound to muscle proteins. A good quantitative agreement was found for the levels of ATP, CP and sugar phosphates (SP) when estimated by NMR or enzymatic assays. Since the chemical shifts of the P(i) and sugar phosphate resonances are a function of the pH, the intracellular pH could be directly deduced from the NMR spectra. Values obtained in this manner were, within the errors of both methods, the same as those determined in iodoacetate/KCl homogenates. The pH gradients within the tissue never exceeded 0.3 pH units. In a final set of experiments we used (31)P-NMR 10 study the effects of electrical stimulation on the intracellular pH and post-mortem metabolism. It was concluded that (31)P-NMR, due to its non-invasive nature plus the fact that some of the NMR parameters are sensitive to the intracellular environment, provides a useful complement to existing methods for the study of post-mortem metabolism.