Effects of feeding diets varying in energy and nutrient density to Hy-Line W-36 laying hens on production performance and economics.

The objectives of this study were to evaluate the effects of feeding 5 different energy and nutrient dense diets to Hy-Line W-36 hens on long-term performance and economics. A total of 480 19 wk old Hy-Line W-36 Single Comb White Leghorn hens were weighed and randomly allocated to 6 replicate groups of 16 hens each (2 adjacent cages containing 8 hens per cage, 60.9×58.4 cm) per dietary treatment in a randomized complete block design. The hens were fed 5 treatment diets formulated to contain 85, 90, 95, 100, and 105% of the energy and nutrient recommendations stated in the 2009 Hy-Line Variety W-36 Commercial Management Guide. Production performance was measured for 52 wk from 19 to 70 wk age. Over the course of the trial, a significant increasing linear response to increasing energy and nutrient density was seen for hen-day egg production, egg weight, egg mass, feed efficiency, energy intake, and body weight (BW). Feed intake showed no significant linear level response to increasing energy and nutrient density except during the early production cycle. No consistent responses were noted for egg quality, percent yolk, and percent egg solids throughout the study. Significant linear responses due to energy and nutrient density were seen for egg income, feed cost, and income minus feed cost. In general, as energy and nutrient density increased, egg income and feed cost per hen increased, but income minus feed cost decreased. Overall, these results indicate that feeding Hy-Line W-36 hens increasing energy and nutrient-dense diets will increase egg production, egg weight, egg mass, feed efficiency, energy intake, BW, egg income, and feed cost, but decrease egg income minus feed cost. However, these benefits do not take effect in early production and seem to be most effective in later stages of the production cycle, perhaps "priming" the birds for better egg-production persistency with age.

Evaluation of limit feeding varying levels of distillers dried grains with solubles in non-feed-withdrawal molt programs for laying hens.

An experiment was conducted with 672 Hy-Line W-36 Single Comb White Leghorn hens (69 wk of age) to evaluate the effects of feeding varying levels of corn distillers dried grains with solubles (DDGS) with corn, wheat middlings, and soybean hulls on long-term laying hen postmolt performance. The control molt treatment consisted of a 47% corn:47% soybean hulls (C:SH) diet fed ad libitum for 28 d. Hens fed the other 7 treatments were limit fed 65 g/hen per day for 16 d, and then fed 55 g/hen per day for 12 d. Hens on treatments 2 and 3 were fed 49% C:35% wheat middlings (WM) or SH:10% DDGS diets (C:WM:10DDGS, C:SH:10DDGS). Hens on treatments 4 and 5 were fed 49% C:25% WM or SH:20% DDGS diets (C:WM:20DDGS, C:SH:20DDGS). Those on treatments 6 and 7 were fed 47% C:47% DDGS (C:DDGS) or 47% WM:47% DDGS (WM:DDGS) diets. Those on treatment 8 were fed a 94% DDGS diet. At 28 d, all hens were fed a corn-soybean meal layer diet (16% CP) and production performance was measured for 36 wk. None of the hens fed the molt diets went completely out of production, and only the C:SH and C:SH:10DDGS molt diets decreased hen-day egg production to below 5% by wk 4 of the molt period. Postmolt egg production was lowest (P < 0.05) for the C:WM:20DDGS treatment. No differences (P > 0.05) in egg weights were detected among treatments throughout the postmolt period. In addition, no consistent differences were observed among treatments for egg mass throughout the postmolt period. Overall results of this study indicated that limit feeding diets containing DDGS at levels of 65 or 55 g/hen per day during the molt period did not cause hens to totally cease egg production.

Evaluation of limit feeding corn and distillers dried grains with solubles in non-feed-withdrawal molt programs for laying hens.

An experiment was conducted using 504 Hy-Line W-36 Single Comb White Leghorn hens (69 wk of age) randomly assigned to 1 of 7 treatments. These treatments consisted of a 47% corn:47% soy hulls diet (C:SH) fed ad libitum; a 94% corn diet fed at a rate of 36.3, 45.4, or 54.5 g/hen per day (CORN 36, CORN 45, and CORN 54, respectively); and a 94% corn distillers dried grains with solubles (DDGS) diet fed at the same rates as the previous corn diets (DDGS 36, DDGS 45, and DDGS 54, respectively) during the molt period of 28 d. The intent was to feed the DDGS diets for 28 d; however, all hens on these diets had very low feed intakes and greater than anticipated BW loss. Thus, they were switched to a 16% CP corn-soybean meal layer diet on d 19 of the molt period. At d 28, hens on all treatments were fed the same corn-soybean meal layer diet for 39 wk (73 to 112 wk of age). All DDGS diets and the CORN 36 diet resulted in total cessation of egg production during the molt period and egg production of hens fed the CORN 45, CORN 54, and C:SH diets had decreased to 3 and 4%, respectively, by d 28. Body weight loss during the 28-d molt period ranged from 14% for the CORN 54 diet to approximately 23% for the 3 DDGS diets. Postmolt egg production (5 to 43 wk) was higher for hens fed the DDGS molt diets than those fed the corn diets. There were no consistent differences in egg mass, egg-specific gravity, feed efficiency, or layer feed consumption among molt treatments for the postmolt period. These results indicate that limit feeding corn diet and DDGS diet in non-feed-withdrawal molt programs will yield long-term postmolt performance that is comparable to that observed by ad libitum feeding a C:SH diet.

Hy-Line W-36 and Hy-Line W-98 laying hens respond similarly to dietary phosphorus levels.

Two experiments were conducted to determine if 2 laying hen strains, Hy-Line W-36 and Hy-Line W-98, would respond similarly to being fed corn-soybean meal diets (17% CP and 3.8% Ca) deficient in nonphytate P (NPP). In experiment 1, 3 diets with varying NPP levels (0.10, 0.14, and 0.45%) were fed to 6 replicate groups of 12 hens of each Hy-Line strain from 20 to 50 wk of age. Body weight, egg weight, egg mass, feed intake, and NPP intake were higher for W-98 hens compared with W-36 hens throughout the 30-wk period. The 0.10% NPP dietary treatment was terminated for both strains at 35 wk of age due to similar low egg production. Within each strain, there was no significant difference in egg production performance for hens fed 0.14% NPP compared with hens fed 0.45% NPP. In experiment 2,3 diets with varying levels of NPP (0.10, 0.13, and 0.45%) were fed to 5 replicate groups of 12 hens of each Hy-Line strain from 95 to 112 wk of age. The 0.10% NPP treatment rapidly and severely depressed egg production and was terminated at 99 wk of age for both strains. In addition, egg production and egg mass were depressed similarly in both strains fed 0.13% NPP. In conclusion, this research indicates that Hy-Line W-36 and Hy-Line W-98 hens responded similarly to dietary NPP deficiency, suggesting that both strains have similar NPP requirements.