Supercritical CO2 extraction increases the recovery levels of omega-3 fatty acids in Tetraselmis chuii extracts.

Tetraselmis chuii is a microalgae marketed as ingredient meeting the acceptance criteria for novel foods established by the European Union and can be an important source of healthy fatty acids (FA). The aim of this research was to characterize the FA profile of T. chuii fractions obtained by supercritical carbon dioxide (SCCO2) extraction operating with two sequential co-solvents and to evaluate the effect of biomass pretreatment (freeze/thaw cycles followed by ultrasounds). T. chuii biomass was confirmed to be an important source of omega-3 FA, mainly due to the abundance of α-linolenic acid, and pre-treatment significantly improved the lipid yield. Other omega-3 FA, such as 16:3, 16:4, 18:4, 18:5, 20:3 and 20:5, were also detected in different proportions. When SCCO2 extraction of pretreated and un-pretreated T. chuii was compared with conventional solvent extraction, the nutritional quality indices of the extracts were improved by the use of SCCO2.

Correction: Villalva et al. Antioxidant, Anti-Inflammatory, and Antibacterial Properties of an Achillea millefolium L. Extract and Its Fractions Obtained by Supercritical Anti-Solvent Fractionation against Helicobacter pylori. Antioxidants 2022, 11, 1849.

Table S1 in the Supplementary Material (Phenolic compounds identified in yarrow samples by using HPLC-ESI-QTOF-MS) in the original paper [...].

Evaluation of the interrelated effects of slaughtering, drying, and defatting methods on the composition and properties of black soldier fly (Hermetia illucens) larvae fat.

The interrelated effect of different slaughtering, drying and defatting methods of black soldier fly larvae (BSFL) on the lipid composition and properties of the fat was studied. Blanching and freezing were compared as slaughtering methods, oven or freeze-drying as drying methods, and mechanical pressing or supercritical fluid extraction (SFE) as defatting methods. The different modes of slaughtering, drying, and defatting, along with both binary and ternary interactions caused significant effects on processes yields, lipid composition, moisture content and thermal properties. Thus, considering the defatting degree and the yield in total valued products (defatted meal plus fat), the combination of blanching, freeze-drying plus mechanical pressing was the worst option (51.2% and 87.5%, respectively). In contrast, the other combinations demonstrated better and comparable efficiency, although SFE is preferable for defatting (83.2% and 96.9%, respectively). The content of major fatty acids (lauric, palmitic and myristic acids) was significantly affected by the BSFL treatments, although with unsignificant impact on the total saturated fatty acids content. To preserve the integrity of the fat, the combination of blanching and oven-drying was preferred, as non-thermal methods of slaughtering and drying caused intense lipolysis, releasing free fatty acids (FFA) in the range of 18.6-23.5%. To achieve the lowest moisture content in the fats (≤0.1%), oven-drying with mechanical pressing were desired, regardless of the slaughtering method; while values > 1% were reached for freezing, freeze-drying and SFE. Both differences in FFA and moisture contents caused different thermal behaviors in the samples. Specially, the melting temperature was lower for samples with higher FFA and moisture contents, with a notable difference when freezing, freeze-drying and SFE were combined (14.5 °C vs 30.6 °C, as the mean value for the rest of samples). The different modes of processing did not affect the minor lipid compounds. Therefore, the modes employed for slaughtering, drying, and defatting of BSFL determine, either individually or in combination, the process yields, composition, and properties of the fat.

Reply to Franski, R.; Beszterda-Buszczak, M. Comment on "Villalva et al. Antioxidant, Anti-Inflammatory, and Antibacterial Properties of an Achillea millefolium L. Extract and Its Fractions Obtained by Supercritical Anti-Solvent Fractionation against Helicobacter pylori. Antioxidants 2022, 11, 1849".

Franski and Beszterda-Buszczak [...].

Peripheral modulation of antidepressant targets MAO-B and GABAAR by harmol induces mitohormesis and delays aging in preclinical models.

Reversible and sub-lethal stresses to the mitochondria elicit a program of compensatory responses that ultimately improve mitochondrial function, a conserved anti-aging mechanism termed mitohormesis. Here, we show that harmol, a member of the beta-carbolines family with anti-depressant properties, improves mitochondrial function and metabolic parameters, and extends healthspan. Treatment with harmol induces a transient mitochondrial depolarization, a strong mitophagy response, and the AMPK compensatory pathway both in cultured C2C12 myotubes and in male mouse liver, brown adipose tissue and muscle, even though harmol crosses poorly the blood-brain barrier. Mechanistically, simultaneous modulation of the targets of harmol monoamine-oxidase B and GABA-A receptor reproduces harmol-induced mitochondrial improvements. Diet-induced pre-diabetic male mice improve their glucose tolerance, liver steatosis and insulin sensitivity after treatment with harmol. Harmol or a combination of monoamine oxidase B and GABA-A receptor modulators extend the lifespan of hermaphrodite Caenorhabditis elegans or female Drosophila melanogaster. Finally, two-year-old male and female mice treated with harmol exhibit delayed frailty onset with improved glycemia, exercise performance and strength. Our results reveal that peripheral targeting of monoamine oxidase B and GABA-A receptor, common antidepressant targets, extends healthspan through mitohormesis.

The Interaction of Slaughtering, Drying, and Defatting Methods Differently Affects Oxidative Quality of the Fat from Black Soldier Fly (Hermetia illucens) Larvae.

The interrelation effect of slaughtering, drying, and defatting methods of BSFL on the oxidative quality of the derived fat was studied. Blanching and freezing were compared as slaughtering methods, followed by oven or freeze-drying for drying and mechanical pressing or SFE for defatting. The oxidative state and stability of the extracted fat and defatted meals were monitored immediately after their production, using peroxide value (PV) and Rancimat test, and over 24 weeks of storage. Slaughtering and drying methods had an independent effect on PV, with freezing and freeze-drying being the best methods. Mechanical pressing and SFE were comparable and superior to conventional hexane defatting. Interactions were observed between slaughtering and defatting, drying and defatting, and between all three factors. Generally, freeze-drying combined with any of the slaughtering and defatting methods resulted in the lowest PVs, with mechanical pressing being preferred. Freeze-drying plus mechanical pressing also produced the most stable fats during storage according to the evolution of PV, while the combination of blanching and SFE produced the least stable. A significant correlation was found between the PV at 24 weeks and the antioxidant activity of the fats. Contrary to storage assays, in accelerated Rancimat assays, freeze-dried samples were the least stable, which was partially attributed to the significant correlation with the acid values of the samples. Defatted meals followed a similar pattern to the extracted fat, except for worse oxidation for SFE defatting. Therefore, the different processing methods of slaughtering, drying, and defatting of BSFL differently affect lipid oxidation, with interactions between such successive steps.

Pressurized Liquid Extraction for the Production of Extracts with Antioxidant Activity from Borututu (Cochlospermum angolense Welw.).

Borututu (Cochlospermum angolense Welw.) roots have been described as a rich source of phenolic compounds. Despite the potential of this plant for the production of bioactive extracts, studies reported until now have been scarce, and they have been based on the use of inefficient conventional extraction techniques. In this study, pressurized liquid extraction (PLE) was investigated for the production of borututu root extracts. Different temperatures (50-200 °C) and solvents (water, ethanol, and 50% ethanol:water) were applied. The total phenolic compound (TPC) content, the main phenolic compounds and the in vitro antioxidant activity of the extracts were evaluated. The results were compared with those obtained by conventional decoction with water. The highest concentrations of TPC and antioxidant activity were obtained with 50% ethanol:water, followed by water. The extract obtained with 50% ethanol:water at 150 °C had a TPC concentration of 343.80 mg/g and presented the largest antioxidant activity (1488 and 4979 µmol Trolox/g extract, determined by DDPH and ABTS assay, respectively). These values were considerably higher than those obtained by conventional decoction. Ellagic acid, and ellagic and methyl ellagic acid glycosides were the main phenolic compounds found in the extracts. Therefore, was PLE demonstrated to be a selective and efficient technique to obtain extracts with high concentrations of phenolic compounds and high antioxidant activity form borututu roots.

Effect of Moisture and Oil Content in the Supercritical CO2 Defatting of Hermetia illucens Larvae.

The supercritical defatting of H. illucens was scaled up at 450 bar and 60 °C from a 270 cm3 extraction cell to a vessel five times larger. Then, eight different H. illucens larvae batches, with variable content of oil (16.80-29.17% w/w) and moisture (4.45-15.95% w/w) were defatted. The effect of these parameters on yield and oil composition was analyzed. The presence of moisture in the larvae batch, in the range of the values studied, had no negative effect on the oil recovery efficiency, which was mainly determined by the initial content of oil in the larvae samples. Furthermore, no differences were determined in the fatty acid profile of the oils recovered, which were rich in saturated fatty acids, mainly lauric acid (ca. 50% w/w). Minor lipids, such as squalene and phytosterols, were determined in all the oil samples. The moisture content in the oils extracted was in the range of 0.118-1.706% w/w. Therefore, some samples exceeded the limits recommended for volatile matter in edible fats and oils (0.2%, including moisture). Yet, concerning the oil peroxide index, values were much lower than those corresponding to the oil extracted using hexane.

Antioxidant, Anti-Inflammatory, and Antibacterial Properties of an Achillea millefolium L. Extract and Its Fractions Obtained by Supercritical Anti-Solvent Fractionation against Helicobacter pylori.

The main objective of this work is to evaluate the potential utility of an Achillea millefolium extract (yarrow extract, YE) in the control of H. pylori infection. The supercritical anti-solvent fractionation (SAF) process of YE allowed the obtaining of two different fractions: yarrow's precipitated fraction (YPF), enriched in most polar phenolic compounds (luteolin-7-O-glucoside, luteolin, and 3,5-dicaffeoylquinic acid), and yarrow's separator fraction (YSF), enriched in monoterpenes and sesquiterpenes, mainly containing camphor, artemisia ketone, and borneol. YE was effective in reducing reactive oxygen species (ROS) production in human gastric AGS cells by 16% to 29%, depending on the H. pylori strain. YPF had the highest inhibitory activity (38-40%) for ROS production. YE modulated the inflammatory response in AGS gastric cells, decreasing IL-8 production by 53% to 64%. This IL-8 inhibition also showed a strain-dependent character. YPF and YSF exhibited similar behavior, reducing IL-8 production, suggesting that both phenolic compounds and essential oils could contribute to IL-8 inhibition. YSF showed the highest antibacterial activity against H. pylori (6.3-7.1 log CFU reduction, depending on the strain) and lower MIC (0.08 mg/mL). Results obtained have shown that YE and SAF fractions (YPF and YSF) were effective as antioxidant, anti-inflammatory, and antibacterial agents regardless of the H. pylori strain characteristics.

Appraisal of the suitability of two-stage extraction process by combining compressed fluid technologies of polar lipid fractions from chia seed.

Although triacylglycerols (TAG) are the major constituents of chia oil, it also contains minor lipid fractions that include phospholipids (PL) among other desirable components. Its amphiphilic character and excellent biocompatibility make PL appropriate for numerous applications with technological and nutritional significanceand potential health benefits. Given the difficulties entailed by the PL isolation, the efficiency for extracting such compounds using two environmental friendly techniques, pressurized liquid extraction (PLE) and supercritical fluid extraction (SFE) was evaluated. By using PLE with food-grade ethanol (EtOH), an oil recovery close to 100% was achieved in just 10 min. This oil extract was particularly rich in α-linolenic acid (ALA; 70%) as compared to the oil extracted by SFE (56%). In the case of SFE, the oil recovery was only 87% but increased to 99% when ethanol was added to CO2. However the use of co-solvent did not affect the fatty acid profile of the supercritical extracts or their TAG composition, where the high molecular weight TAG species were the predominant in all cases. With the exception of SFE without co-solvent, all methods applied were capable of extracting the PL fraction, although the content and distribution of the individual components present in this fraction differed markedly depending on the extraction conditions used. In this context, the use of a sequential extraction process, combining SFE and PLE was particularly interesting. The re-extraction by PLE of the chia cake, previously defatted by SFE, allowed to obtain an oil extract highly enriched in PLs, whose content exceeded 16% and with a higher PL species than the rest of the oil extracts.

Production of omega 3-rich oils from underutilized chia seeds. Comparison between supercritical fluid and pressurized liquid extraction methods.

Chia seeds constitute a promising source of α-linolenic acid (ALA). In the present work, an underutilized and cheaper set of chia seeds, which were discarded after the harvest according to quality criteria - named in this work as low oil content seeds (LOCS) - have been evaluated as a potential source for obtaining PUFA-enriched oils against the commonly studied high-quality chia seeds denoted as high oil content seeds (HOCS) in this study. Two efficient and environmental friendly techniques, supercritical fluid extraction (SFE) and pressurized liquid extraction (PLE), were evaluated to optimize the extraction process of chia oil. At 60 °C, by using pressurized food-grade ethanol, recoveries close to 100% were achieved from both sets of seeds in a short extraction time (10 min). By using SFE, the greatest oil extraction yield (>95%) was attained at the highest pressure and temperature conditions (45 MPa and 60 °C) after 240 min. At the early stage of SFE extraction, both LOCS and HOCS exhibited a similar kinetic behavior, reaching oil extraction rates of 0.59 g oil/min and 0.64 g oil/min, respectively. No differences were found between the fatty acid profile of the oils extracted from LOCS and HOCS both by PLE and SFE. ALA and linoleic acid (LA) concentrations ranged between 65-68% and 17-23% respectively, and a predominance of high molecular weight triglycerides (≥ CN50), was found in all extracted oils. In conclusion, LOCS might constitute a new suitable raw material for the production of ALA-enriched oils. Concerning the extraction methods assayed, the oil was almost entirely recovered by both PLE and SFE at the used conditions.

Vaccinium meridionale Swartz extracts and their addition in beef burgers as antioxidant ingredient.

BACKGROUND: Vaccinium meridionale Swartz (mortiño) constitutes a source of bioactive phytochemicals, but reports related to its efficient and green production are scarce. In this study, pressurized liquid extraction (PLE) and ultrasound-assisted extraction of mortiño were compared. Total phenolic content (TPC) and antioxidant capacity (ABTS•+ ) were determined. Beef burgers with 20 g kg-1 of mortiño (MM) or its PLE extract (ME) were manufactured. Lipid oxidation (TBARS) and instrumental color changes were measured after refrigerated storage. RESULTS: High TPC (up to 72 g gallic acid equivalent kg-1 extract) was determined in mortiño extracts, which was positively correlated with antioxidant activity. TBARS values of beef burgers containing either MM or ME did not change after refrigerated storage, whereas lipid oxidation of control burgers increased significantly. The color of burgers with added MM or ME was different (lower b* and a* values) from that of control burgers. However, the evolution of color after storage was similar between control and ME samples. CONCLUSION: Mortiño extracts with high TPC can be obtained by PLE. Both mortiño and its PLE extract are able to control lipid oxidation of beef burgers, but the extract is preferred from the color quality point of view. © 2017 Society of Chemical Industry.

Bioaccessibility and Antioxidant Activity of Calendula officinalis Supercritical Extract as Affected by in Vitro Codigestion with Olive Oil.

Supercritical extracts of marigold (ME) were produced and characterized. The bioaccessibility of terpenes, especially that of pentacyclic triterpenes (PT), the particle-size distribution, and antioxidant activity after the in vitro codigestion of ME with olive oil (OO) were determined. ME produced without cosolvent was richer in taraxasterol, lupeol, α-amyrin, and ß-amyrin than extracts with cosolvent. All terpenes showed high bioaccessibility without OO (>75%). Significant correlations were found between the molecular properties of compounds (logP and number of rotatable bonds) and their bioaccessibility. Codigestion with OO enhanced the bioaccessibility (around 100% for PT), which could be related to a higher abundance of low-size particles of the digestion medium. The antioxidant activity of the digested ME increased around 50%, regardless of OO. PT-rich extracts from marigold display high bioaccessibility and improved antioxidant activity after in vitro digestion, although complete bioaccessibility of PT can be reached by codigestion with oil, without affecting antioxidant activity.

Extraction of thymol from different varieties of thyme plants using green solvents.

BACKGROUND: Thymol (2-isopropyl-5-methylphenol) is the main monoterpene phenol found in thyme essential oil. This compound has revealed several biological properties, including antibacterial, anti-inflammatory and antioxidant activities. In this work, a comparison was made between the performance of different green solvents (ethanol, limonene and ethyl lactate), by pressurized liquid extraction (PLE) and supercritical fluid extraction (SFE) at different conditions, to extract thymol from three different varieties of thyme (Thymus vulgaris, Thymus zygis and Thymus citriodorus). Additionally, new solubility data of thymol in limonene and ethanol at ambient pressure and temperatures in the range 30-43 °C are reported. RESULTS: The highest thymol recoveries were attained with T. vulgaris (7-11 mg g(-1)). No thymol could be quantified in the PLE samples of T. citriodorus. The highest concentrations of thymol in the extracts were obtained with limonene. Thymol is very soluble in both solvents, particularly in ethanol (∼900 mg g(-1) at ∼40 °C), and is the main compound (in terms of peak area) present in the essential oil extracts obtained. CONCLUSION: The three solvents show good capacity to extract thymol from T. vulgaris and T. zygis by PLE. Although PLE proved to be a suitable technology to extract thymol from thyme plants, the highest concentrations of thymol were obtained by SFE with supercritical CO2 .