Potential of microalgae as source of health-beneficial bioactive components in produced eggs.

In line with the growing interest in humans' nutrition, production of microalgae-based functional foods characterized by an increased content of bioactive substances is attractive. The aim of this study was to investigate the potential of microalgae as additives to feed for laying hens, to enrich the eggs with polyunsaturated fatty acids (PUFA) and selenium/carotenoid antioxidants. Our results showed that supplementation of hens by feed containing 1% of Trachydiscus minutus or 1% of Japonochytrium marinum leads to increase of long-chain PUFA in eggs by 26-66%. Addition of 1% of Scenedesmus obliquus to feed causes the increase of lutein and cantaxanthin in eggs by 48% and 18%, respectively, and addition of 0.5% selenium enriched Chlorella vulgaris increases the final content of organic selenium in eggs by 100-152%. As concerns selenium, it is important to notice that its bioavailability has to be considered. Despite the higher concentration of total selenium in Vischeria helvetica than in C. vulgaris, its bioaccessibility in Vischeria was limited, thus out of usage for feeding purposes. Administration of combinations of selenium enriched Chlorella + Japonochytrium and Chlorella + Schizochitrium verified the increased concentrations of organic selenium, PUFA, as well as carotenoids, with no adverse effect on quality and productivity of eggs. The study confirmed the potential of both traditional as well as new microalgae to be used as feed supplements for functional eggs production. The supplementation of hens by specific microalgae combinations could be advantageous in terms of spectrum of bioactive compounds present.

Determination of fumonisins B1 and B2 in corn by LC/MS with immunoaffinity column cleanup: interlaboratory study.

An interlaboratory validation study was conducted to establish the method performance characteristics of an immunoaffinity column (IAC) cleanup procedure followed by LC/MS for the determination of fumonisins B1 (FB1) and B2 (FB2) and combined FB1 + FB2 in corn. The test portion is extracted with acetonitrile-methanol-water (25 + 25 + 50). The extract is filtered, diluted with phosphate-buffered saline solution, and applied to an IAC. FB1 and FB2 are removed with methanol, followed by water, then directly determined by RPLC with MS detection using selected-ion monitoring of two characteristic ions in each case. Naturally contaminated corn samples were milled to a fine powder and mixed to produce three samples with target levels of combined FB1 + FB2 ranging from 350 to 4000 microg/kg. Of 15 initially participating laboratories, two failed to report results and another did not follow the prescribed method. Thus, valid results were obtained from 12 participants located in 11 countries. Statistical analysis of the results produced RSDr values of 4.6-11.9, 1.9-12.6, and 1.4-11.5% for FB1, FB2, and combined FB1 + FB2, respectively; the corresponding RSDR values were 19.8-23.8, 18.2-25.5, and 18.8-23.2%. The three concentration levels of combined FB1 + FB2 were 534, 1194, and 1954 microg/kg. HorRat values for r and R were all < 2.0, indicating that the method is suitable as a regulatory method for the enforcement of European Union limits for fumonisins in corn.

Novel approaches in analysis of Fusarium mycotoxins in cereals employing ultra performance liquid chromatography coupled with high resolution mass spectrometry.

Rapid, simple and cost-effective analytical methods with performance characteristics matching regulatory requirements are needed for effective control of occurrence of Fusarium toxins in cereals and cereal-based products to which they might be transferred during processing. Within this study, two alternative approaches enabling retrospective data analysis and identification of unknown signals in sample extracts have been implemented and validated for determination of 11 major Fusarium toxins. In both cases, ultra-high performance liquid chromatography (U-HPLC) coupled with high resolution mass spectrometry (HR MS) was employed. (13)C isotopically labeled surrogates as well as matrix-matched standards were employed for quantification. As far as time of flight mass analyzer (TOF-MS) was a detection tool, the use of modified QuEChERS (quick easy cheap effective rugged and safe) sample preparation procedure, widely employed in multi-pesticides residue analysis, was shown as an optimal approach to obtain low detection limits. The second challenging alternative, enabling direct analysis of crude extract, was the use of mass analyzer based on Orbitrap technology. In addition to demonstration of full compliance of the new methods with Commission Regulation (EC) No. 401/2006, also their potential to be used for confirmatory purposes according to Commission Decision 2002/657/EC has been critically assessed.

Transfer of Fusarium mycotoxins and 'masked' deoxynivalenol (deoxynivalenol-3-glucoside) from field barley through malt to beer.

The fate of five Fusarium toxins--deoxynivalenol (DON), sum of 15- and 3-acetyl-deoxynivalenol (ADONs), HT-2 toxin (HT-2) representing the main trichothecenes and zearalenone (ZON) during the malting and brewing processes--was investigated. In addition to these 'free' mycotoxins, the occurrence of deoxynivalenol-3-glucoside (DON-3-Glc) was monitored for the first time in a beer production chain (currently, only DON and ZON are regulated). Two batches of barley, naturally infected and artificially inoculated with Fusarium spp. during the time of flowering, were used as a raw material for processing experiments. A highly sensitive procedure employing high-performance liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) was validated for the analysis of 'free' Fusarium mycotoxins and DON-conjugate in all types of matrices. The method was also able to detect nivalenol (NIV), fusarenon-X (FUS-X) and T-2 toxin (T-2); nevertheless, none of these toxins was found in any of the samples. While steeping of barley grains (the first step in the malting process) apparently reduced Fusarium mycotoxin levels to below their quantification limits (5-10 microg kg(-1)), their successive accumulation occurred during germination. In malt, the content of monitored mycotoxins was higher compared with the original barley. The most significant increase was found for DON-3-Glc. During the brewing process, significant further increases in levels occurred. Concentrations of this 'masked' DON in final beers exceeded 'free' DON, while in malt grists this trichothecene was the most abundant, with the DON/DON-3-Glc ratio being approximately 5:1 in both sample series. When calculating mass balance, no significant changes were observed during brewing for ADONs. The content of DON and ZON slightly decreased by a maximum of 30%. Only traces of HT-2 were detected in some processing intermediates (wort after trub removal and green beer).