Temperature and humidity within the clothing microenvironment.

The present study investigates clothing microenvironment conditions that may develop during prolonged exposure of workers to a hot environment. Five subjects were exposed to a linear increase in ambient temperature from 20-40 degrees C over a 90-min period, and then remained at 40 degrees C for an additional 90 min. During the exposures, subjects were clad in four types of helicopter personnel suits (Gore-Tex, Cotton Ventile, Nomex/Insulite, and Nomex/Neoprene), incorporating both dry-suit and wet-suit designs. Continuous assessment was made of skin temperature, rectal temperature, and of microenvironment temperature, relative humidity, and vapor pressure (T mu, RH mu, and VP mu) 8 mm from the surface of the skin. Results indicate that although microenvironment temperatures were similar among suits and slightly lower than that of the environment, the RH mu and VP mu were much greater than those of the ambient air. The Nomex/Insulite and Nomex/Neoprene suits showed the highest VP mu, of which only the Nomex/Insulite resulted in significantly greater increases in rectal temperature, likely due to complete covering of the body with the impermeable insulite component. The present study demonstrates the need to discern between the ambient conditions and the conditions encountered next to the skin when protective clothing is worn.

Changes in insulation of wetsuits during repetitive exposure to pressure.

This investigation was intended to a) establish a relationship between pressure and thickness (and hence insulation) of wetsuits during acute changes in pressure from 0.5 to 5 atmospheres absolute (ATA); b) determine the effect of repetitive compression-decompression (C-D) procedures on the insulation properties of wetsuits; and c) assess the possible recovery of insulation after cessation of repetitive C-D. Various wetsuits with different thicknesses and types of linings were selected. In all wetsuits, insulation and thickness were both reduced as similar, curvilinear functions of acutely increasing pressure in the range of 0.5-5.0 ATA. Effects of repetitive C-D (3 ATA) were studied in 5-mm-thick suit samples with various linings. The insulation of suits (0.100-0.120 degrees C.W-1.m-2) rapidly decreased after the first 5000 C-D. In suits without linings (skin suits), the insulation was reduced to 0.080 degrees C.W-1.m-2 at 5000 C-D and revealed no further reduction during the continuation of C-D cycles up to 30,000. Suits lined with single- or double-sided jersey showed a continuous decrease in the insulation and thickness as the number of cycles increased up to 12,000 and remained at a lowered value (0.060 degrees C.W-1.m-2) until the termination of C-D (30,000 times). A nearly complete recovery of thickness was seen 10 days after cessation of C-D treatment in the skin suit when C-D cycles were less than 3500; however, no recovery was observed in suits with linings (either single- or double-sided) in 25 days.(ABSTRACT TRUNCATED AT 250 WORDS)