Determination of low tetanus or diphtheria antitoxin titers in sera by a toxin neutralization assay and a modified toxin-binding inhibition test.

A method for the screening of tetanus and diphtheria antibodies in serum using anatoxin (inactivated toxin) instead of toxin was developed as an alternative to the in vivo toxin neutralization assay based on the toxin-binding inhibition test (TOBI test). In this study, the serum titers (values between 1.0 and 19.5 IU) measured by a modified TOBI test (Modi-TOBI test) and toxin neutralization assays were correlated (P < 0.0001). Titers of tetanus or diphtheria antibodies were evaluated in serum samples from guinea pigs immunized with tetanus toxoid, diphtheria-tetanus or triple vaccine. For the Modi-TOBI test, after blocking the microtiter plates, standard tetanus or diphtheria antitoxin and different concentrations of guinea pig sera were incubated with the respective anatoxin. Twelve hours later, these samples were transferred to a plate previously coated with tetanus or diphtheria antitoxin to bind the remaining anatoxin. The anatoxin was then detected using a peroxidase-labeled tetanus or diphtheria antitoxin. Serum titers were calculated using a linear regression plot of the results for the corresponding standard antitoxin. For the toxin neutralization assay, L+/10/50 doses of either toxin combined with different concentrations of serum samples were inoculated into mice for anti-tetanus detection, or in guinea pigs for anti-diphtheria detection. Both assays were suitable for determining wide ranges of antitoxin levels. The linear regression plots showed high correlation coefficients for tetanus (r(2) = 0.95, P < 0.0001) and for diphtheria (r(2) = 0.93, P < 0.0001) between the in vitro and the in vivo assays. The standardized method is appropriate for evaluating titers of neutralizing antibodies, thus permitting the in vitro control of serum antitoxin levels.

Determination of low tetanus or diphtheria antitoxin titers in sera by a toxin neutralization assay and a modified toxin-binding inhibition test

A method for the screening of tetanus and diphtheria antibodies in serum using anatoxin (inactivated toxin) instead of toxin was developed as an alternative to the in vivo toxin neutralization assay based on the toxin-binding inhibition test (TOBI test). In this study, the serum titers (values between 1.0 and 19.5 IU) measured by a modified TOBI test (Modi-TOBI test) and toxin neutralization assays were correlated (P < 0.0001). Titers of tetanus or diphtheria antibodies were evaluated in serum samples from guinea pigs immunized with tetanus toxoid, diphtheria-tetanus or triple vaccine. For the Modi-TOBI test, after blocking the microtiter plates, standard tetanus or diphtheria antitoxin and different concentrations of guinea pig sera were incubated with the respective anatoxin. Twelve hours later, these samples were transferred to a plate previously coated with tetanus or diphtheria antitoxin to bind the remaining anatoxin. The anatoxin was then detected using a peroxidase-labeled tetanus or diphtheria antitoxin. Serum titers were calculated using a linear regression plot of the results for the corresponding standard antitoxin. For the toxin neutralization assay, L+/10/50 doses of either toxin combined with different concentrations of serum samples were inoculated into mice for anti-tetanus detection, or in guinea pigs for anti-diphtheria detection. Both assays were suitable for determining wide ranges of antitoxin levels. The linear regression plots showed high correlation coefficients for tetanus (r² = 0.95, P < 0.0001) and for diphtheria (r² = 0.93, P < 0.0001) between the in vitro and the in vivo assays. The standardized method is appropriate for evaluating titers of neutralizing antibodies, thus permitting the in vitro control of serum antitoxin levels.

Effect of medium composition on the production of tetanus toxin by Clostridium tetani

The tetanus toxin is a neurotoxin synthesized by the bacillus Clostridium tetani that, after detoxification with formaldehyde, still exhibits antigenic and immunologic properties, hence its denomination of tetanus toxoid. Such a neurotoxin is produced by cultivation of the microorganism in vegetative form on a relatively complex specific medium containing glucose and peptone. The simultaneous effects of the starting levels of glucose (G0) and N-Z Case TT (NZ0) as carbon and nitrogen sources, respectively, on the production of tetanus toxin have been investigated in this work in static cultivations by means of a five-level star-shaped experimental design and evaluated by response surface methodology (RSM) for optimization purposes. The highest final average yield of tetanus toxin (72 Lf/mL), achieved at G0= 9.7 g/L and NZ0= 43.5 g/L, was 80% higher than that obtained with standard cultivations (G0= 8.0 g/L and NZ0= 25.0 g/L).

Use of sephacryl high resolution (HR) in tetanus anatoxin purification.

The tetanus purified anatoxin is used in the preparation of the tetanus toxoid and multiple vaccines (dT, DT and DTP), all of them strictly following specifications established by the WHO with a minimum antigenic purity equal to 1,000 Lf/mgPN. Aiming to establish more sensitive and accurate methods for purification, samples from four different lots of tetanus anatoxin were submitted to gel filtration in twenty independent trials using the Sephacryl S-100 HR and S-200 HR resins. The Authors were careful to optimize their parameters of performance as to sample volume, elution and selectivity flow for tetanus anatoxin purification, allowing their use in industrial scale. The Sephacryl S-100 HR resin presented the best selectivity, that is, the best separation, allowing a greater linear-flow and, consequently, the best purity index. Satisfactory results were also achieved with the Sephacryl S-200 HR resin after optimization of chromatographic parameters for elution flow and volume of the sample applied. The good results of purification obtained, as well as the high chemical stability, have pointed out both the Sephacryl S-100 HR and S-200 HR resins as equally efficient for industrial production.

Development and validation study for the chromatographic purification process for tetanus anatoxin on Sephacryl S-200 High Resolution.

The tetanus purified anatoxin is used in the preparation of multiple immunoprophylactics. WHO (World Health Organization) specifies that the tetanus anatoxin must exhibit a degree of purity greater than or equal to 1,000 Lf/mg protein nitrogen (PN). Today liquid chromatography is a well established technique for the purification of tetanus anatoxin and several different methods are used in production scale. On a small scale, we purified tetanus anatoxin on Sephacryl S-200 High Resolution (gel filtration) and we obtained a successful high-yield purification. On the basis of these results, by combining conventional tangential flow filtration (TFF) at 50,000 N.M.W.L. (Nominal Molecular Weight Limit) ultrafiltration membrane with gel filtration on Sephacryl S-200 High Resolution, we have been able to purify 14 lots of tetanus anatoxin using the Bioprocess System (Amersham Pharmacia Biotech) to a large scale operation. Using this method, 77,401,332 doses of tetanus toxoid were prepared in 14 consecutive lots, supporting the reproducibility and reliability of the method presented here.

Production of an effective anti-Bothrops-tetanus mixed hyperimmune serum of equine origin

The present investigation reveals the possibility of simultaneous immunization of horses with Bothrops or Crotalus snake venoms and Tetanus antigens for the production of anti-Bothrops-Tetanus or anti-Crotalus-Tetanus mixed serum, with high titers of the respective specific antibodies. Bothrops antivenoms with an average neutralizing titer of 4.16 mg venom/ml were obtained from plasma of horses with titers lower than 0.5 mg venom/ml when Tetanus antigens were not used. This suggests the existence of a synergism between Bothrops venoms and Tetanus antigens in the stimulation of the antibody response. The pooled plasma of the animal had a neutralizing titer of 21.0 mg/ml reference Bothrops venoms and 3,300 IU/ml to Tetanus antigens after purification by enzymatic digestion and ammonium sulphate precipitation. These experiments lead us to conclude that Bothrops envenomation therapy can be successfully performed using Anti-Bothrops-Tetanus serum also serving as Tetanus prophylaxis. anti-Crotalus-Tetanus serum can also be produced, although it is not of medical interest as Crotalus envenomation rarely results in local necrotizing lesions.

Specific peptides of casein pancreatic digestion enhance the production of tetanus toxin.

Casein pancreatic digest is the basic bacterial growth medium used for diphtheria, botulinum and tetanus toxin vaccine production. It is known that the variation in the peptide content of the casein digest directly affects final toxin yields. In this study, the identification and sequences of eight peptides, four to eight amino acids in length, of casein pancreatic digestion, which seem to be involved in the enhancement of tetanus toxin production, are described. They all contain one or two residues of proline/molecule and a predominance of hydrophobic amino acid residues. The most active peptides show a general structure of Pro-aromatic-Pro, and this pattern resembled the motif displayed by bradykinin-potentiating peptides found in snake venoms. By analogy with the mechanism of bradykinin potentiation through inhibition of the proteolytic degradation of bradykinin, it is suggested that the six peptides identified here could protect the tetanus toxin from proteolysis, once secreted by the bacteria.